BioMed Research International

Volume 2013 (2013), Article ID 479742, 6 pages

http://dx.doi.org/10.1155/2013/479742

Research Article

Improvement of Daptomycin Production in Streptomyces roseosporus through the Acquisition of Pleuromutilin Resistance

Linli Li,¹ Tingmei Ma,¹ Qing Liu,¹ Yuqi Huang,¹ Changhua Hu,1,2 and Guojian Liao1,2

¹Institute of Modern Biopharmaceuticals, School of Pharmaceutical Sciences, Southwest University, Chongqing 400715, China

²Chongqing Engineering Research Center for Pharmaceutical Process and Quality Control, Southwest University, Chongqing 400715, China

Received 28 April 2013; Revised 8 July 2013; Accepted 22 July 2013

Academic Editor: Marco Bazzicalupo

Copyright © 2013 Linli Li et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract.

Daptomycin, a cyclic lipopeptide antibiotic produced by Streptomyces roseosporus, displays potent activity against a variety of gram-positive pathogens. There is a demand for generating high-producing strains for industrial production of this valuable antibiotic. Ribosome engineering is a powerful strategy to enhance the yield of secondary metabolites. In this study, the effect of a diterpenoid antibiotic pleuromutilin resistance mutation on daptomycin production was assessed. Spontaneous pleuromutilin-resistant derivatives of S. roseosporus were isolated. Sequencing of rplC locus (encoding the ribosomal protein L3) showed a point mutation at nt 455, resulting in the substitution of glycine with valine. G152V mutants showed increased production of daptomycin by approximately 30% in comparison with the wild-type strain. Its effect on daptomycin production was due to enhanced gene transcription of the daptomycin biosynthetic genes. In conclusion, pleuromutilin could be used as a novel ribosome engineering agent to improve the production of desired secondary metabolites.

1. Introduction

Daptomycin (Figure 1) is a cyclic lipopeptide produced by Streptomyces roseosporus. It shows excellent activity against Gram-positive pathogens, including methicillin-resistant Staphylococcus aureus (MRSA) or vancomycin-resistant Enterococci (VRE) [1]. Daptomycin has been approved for use in skin, skin-structure infections, and right-side endocarditis caused by S. aureus [2]. Daptomycin is a member of the A21978C factors consisting of 13 amino acids and a fatty acid which ranges from 10 to 13 carbon atoms [3]. Due to its pharmacological importance, considerable attention has been paid to the enhancement of the yield of daptomycin [4–7].

(a)

(b)

Figure 1: Chemical structures of pleuromutilin and daptomycin.

Ribosome engineering has been proved to be an efficient way for enhancing the production of secondary metabolites in a wide range of structural classes from a variety of actinomycetes strains [8]. Mutants could be easily obtained by simply screening resistant strains on drug-containing plates. Antibiotics targeting bacterial ribosome, such as streptomycin, gentamicin, and erythromycin, or targeting bacterial RNA polymerases, such as rifamycin, have been widely used to generate mutants with enhanced production of desired secondary metabolites [9–12]. Previous study in our lab demonstrated that K43N mutant in ribosomal protein S12 of S. roseosporus led to increased A21978C production by approximately 2.2-fold compared with the wild-type strain [13].

Pleuromutilin is a diterpenoid antibiotic that acts by targeting large subunit of the bacterial ribosome and interacts with the peptidyl transferase center [14]. Resistance to pleuromutilin due to ribosome mutation has been demonstrated in a limited number of organisms [15–18]. However, the effect of pleuromutilin resistance mutation on antibiotic production in Streptomyces has not been reported. Therefore, we examined whether the acquisition of resistance to pleuromutilin enabled S. roseosporus to overproduce daptomycin.

2. Materials and Methods

2.1. Bacterial Strains and Growth Conditions

Bacterial strains used in this study are listed in Table 1. Streptomyces roseosporus ploxp, a producer of daptomycin, contained a reporter system which facilitated the selection of daptomycin overproducing strains [13]. Micrococcus luteus was used as the indicator strain for daptomycin bioassay.

Table 1: Bacterial strains used in this study.

Strains
Description
Reference

Streptomyces roseosporus ploxp
Wild-type strain containing a reporter plasmid in which pdptE was inserted in front of neo
[13]

S.  roseosporus PL
rplC G152V, Pler derivative of ploxp
This study

S.  roseosporus L2H
rplC G152V, Pler derivative of ploxp
This study

S.  roseosporus PL11
rplC G152V, Pler derivative of ploxp
This study

S.  roseosporus LDR
Pler derivative of ploxp with unknown mutation site
This study

S.  roseosporus M234
Pler derivative of ploxp with unknown mutation site
This study

Micrococcus  luteus
Daptomycin-sensitive indicator strain
[13]

Ploxp and its derivative strains were grown at 28°C in different media. Solid medium AS-1 and liquid medium TSB were prepared as described elsewhere [19]. F10A medium (CaCO₃ 0.3%, distillers soluble 0.5%, soluble starch 2.5%, yeast extract 0.5%, glucose 0.5%, bactopeptone 0.5%) was used for daptomycin production. Decanoic acid (1% V/V in methyl oleate) was fed to the shake flask during fermentation to produce daptomycin.

2.2. DNA Manipulations

Molecular biology techniques were performed as described previously [20, 21]. Enzymes were purchased from Takara or TransGen and used according to the manufacturers’ instructions. The FastPfu PCR system (TransGen) was used in PCR. Oligonucleotides (Table 2) were purchased from Invitrogen. DNA sequencing was carried out by the BGI technology.

Table 2: Primers used for PCR amplification of target genes.

Primer name
Description
Sequence

rplCF
Primes upstream of rplC
GGTGAACAAGCCCCTCAAG

rplCR
Primes downstream of rplC
GGTCAGGTTCTGGGTGGTG

23rRNAF
Primes upstream of 23S rRNA
AGAGACCAGCGAGAAGCGACT

23rRNAR
Primes downstream of 23S rRNA
GAACGTAGCCAACCAGCCAT

2.3. Generation and Selection of Pleuromutilin-Resistant (Pler) Strains

10¹⁶ spores of pSRE were spread out on AS-1 plate containing various concentrations of pleuromutilin. The resulting spontaneous mutants were dotted on plates containing various amounts of kanamycin and 20 μg mL⁻¹ apramycin and then incubated at 28°C for three days. The resulting kanamycin-resistant mutants were used for further fermentation study. In the meantime, genomic DNAs were extracted from these mutants and used as templates for the amplification of rplC and 23S rRNA DNA fragment by PCR with primer pairs rplCF/rplCR and 23rRNAF/23rRNAR.

2.4. Fermentation of S. roseosporus and Daptomycin Bioassay

Spores of S. roseosporus and its derivatives were inoculated in TSB. The cultures were grown at 28°C on a rotary shaker (220 rpm) for 48 h and used as seed culture. One mL (2% V/V) of seed culture was inoculated into flasks containing 50 mL of F10A medium and then fermented at 28°C on a rotary shaker (220 rpm) for 6 days. The culture filtrates harvested by centrifugation were used for the determination of the cell dry weight and daptomycin bioassay as described [5]. To determine the cell dry weight, 10 mL cell cultures were collected by centrifugation. The cell pellet was washed with distilled water, collected by centrifugation, and dried at 60°C to constant weight.

3. Results

3.1. Isolation and Characterization of Spontaneous Pler  S. roseosporus Mutants

Spontaneous S. roseosporus mutants resistant to pleuromutilin were rarely isolated. From approximately 4 × 10¹⁶ spores, only 42 colonies were formed on AS-1 agar supplemented with 150 μg mL⁻¹ or 250 μg mL⁻¹ of pleuromutilin, which corresponds to approximately 3- to 5-fold amount of minimum inhibitory concentration (MIC). Spontaneous mutants could be isolated at a frequency of approximately 10⁻¹⁵.

Pleuromutilin binds to the ribosomal peptidyl transferase center. Spontaneous pleuromutilin resistance is often associated with mutations in ribosomal protein subunits or rRNA which prevent the antibiotic from binding to the ribosome. Common examples of these mutations include substitution of Asn148 of the L3 ribosomal protein subunit, which is encoded by the rplC gene or nucleotide positions 2032, 2055, and 2447 of the 23S rRNA [17, 18]. To investigate the basis of pleuromutilin resistance in S. roseosporus, we randomly selected 10 strains and extracted their genomic DNA as the temple for PCR amplification. The rplC and 23rRNA gene loci were amplified and sequenced, respectively. No mutations in 23S rRNA were observed, whereas 8 strains carried a single point mutation in the rplC gene which would lead to an amino acid change at codon 455, resulting in substitution of glycine with valine, and 2 mutants harbored uncharacterized mutations outside of rplC and 23S rRNA (Table 3). As expected, all 10 strains exhibited little or no resistance to streptomycin or rifapicin (data not shown).

Table 3: Daptomycin phenotypes and genotypes of rplC mutants.

Strain
Daptomycin phenotype
Codon 455 sequence
Corresponding Amino acid

Amino acid change

ploxp
Wild type
GGT
Glycine
None

PL, L2H, and PL11
Daptomycin overproducer
GTT
Valine
G152V

LDR, M234*
Daptomycin overproducer
GGT
Glycine
None

 *Mutation site uncharacterized.

3.2. Daptomycin Production by Pler Mutants

The effects of rplC mutation and the unknown mutation on daptomycin production in fermentation cultures were assessed. 3G152V mutants and 2 mutants with unknown mutation sites were cultured in F10A liquid medium for 6 days and then the titer of daptomycin was measured. All 5 strains produced enhanced amounts of daptomycin compared to the wild-type strain (Figure 2(a)). These results suggest that different types of pleuromutilin resistance mutations positively affected the ability of S. roseosporus to produce daptomycin.

(a)

(b)

(c)

Figure 2: Daptomycin production and biomass of S. roseosporus and mutants. (a) Daptomycin production in S. roseosporus and mutants at 6 days; (b) cell dry weight; (c) daptomycin production in ploxp, PL11, and LDR. Data are presented as the averages of the results of three independent experiments. Error bars show standard deviations.

To further clarify the effect of rplC mutation on fitness of the organism and daptomycin production. PL11 with G152V mutation, LDR with unknown mutation site, and wild-type strains were cultured in fermentation medium and were measured the daptomycin titer and cell mass during the entire time course. The two strains had comparable growth rates and final cell densities, indicating that higher cell density was not the mechanism for daptomcyin overproduction (Figure 2(b)). PL11 and LDR produced daptomycin in higher amount than the wild-type strain during the entire time course (Figure 2(c)).

To investigate the stability of PL11, the mutant was incubated in the absence of pleuromutilin. After 5 passages, 5 colonies were randomly selected and cultured in the presence of pleuromutilin for 5 days (about 150 generations). All of them still conferred pleuromutilin resistance and produced 1.3-fold of yields of daptomycin compared with the parent strain (data not shown). These results demonstrated that a PL11 mutant is genetically stable.

3.3. Effect of rplC Mutations on Gene Expression of Daptomycin Biosynthetic Genes

To determine the effect of rplC mutation on transcription of daptomycin gene cluster, a transcription reporter system was used. ploxp and PL11 contained the chromosomal pdptE::neo transcriptional reporter fusion [13]. This reporter system was based on the assumption that the expression level of antibiotic biosynthetic genes positively correlated with the titer of daptomycin. The kanamycin resistance ability was measured and PL11 displayed higher kanamycin-resistant level than the wild-type strain, implying that the gene expression of dptE was enhanced (Figure 3). As the whole gene cluster ranging from dptE to dptJ and the contiguous genes from dptE to dptH may be transcribed on a giant polycistronic transcript [22], rplC mutations could result in increased gene transcription of the whole daptomycin gene cluster, which accounts for the observed effect of rplC mutation on daptomycin production.

(a)

(b)

Figure 3: Kanamycin resistance level among S. roseosporus and its derivatives. (1) ploxp, a strain containing a reporter system in which pdptE was inserted in front of neo; (2) PL11, were derivatives of ploxp with rplC mutation; (3) LDR, derivatives of ploxp-harboring uncharacterized mutation site. (a) Without kanamycin; (b) 400 μg mL⁻¹ kanamycin.

4. Discussion

A mutation that confers to resistance to a drug targeting bacterial ribosomes, such as streptomycin, gentamicin, and paromomycin, is a powerful approach to enhancing the production of secondary metabolites in a wide range of structural classes [23]. In this study, we assess the beneficial effect of pleruomutilin on daptomycin production. The pleuromutilin classes of antibiotics are protein synthesis inhibitors that target the 50S subunit of bacterial ribosome. It was used for veterinary applications for more than 30 years and was recently approved for human use in 2007 [24]. Both the G152V mutant and mutants with uncharacterized mutation site increased the daptomycin significantly and produced daptomycin in higher amount than the wild-type strain during the entire time course, demonstrating that pleuromutilin could be used as a novel agent for ribosome engineering.

Pleuromutilin was characterized by a low spontaneous mutation frequency of 10⁻⁹-10⁻¹⁰ against S. aureus and other organisms tested [17]. It was far more difficult to isolate spontaneous mutation in S. roseosporus, at a frequency of approximately 10⁻¹⁵. We tried a couple of times to isolate mutants from S. coelicolor using as high as 10¹⁷ spores, but unfortunately no mutants were obtained, demonstrating that pleuromutilin had a very low spontaneous mutation frequency in Streptomyces. It must be pointed out that the extremely low mutation rate in S. roseosporus was unusual and may result from secondary mutation in the genome to compensate the lethal effect of rplC mutation. Further investigations such as whole genome sequencing are required to elucidate the mechanism underling the pleuromutilin resistance.

A number of lines of evidence showed that   S. aureus and other pathogens were predominantly linked to rplC mutations rather than to 23S rRNA mutation [18]. L3 protein consisted of about 210 amino acids and its mutation resistant to pleuromutilin centered to C-terminal. For example, G155R, D159Y, or S158L changes in the L3 protein were identified in S. aureus [17]. In this study, we identified a novel site G152V, which would enrich the mutation site pools and facilitate revealing the mechanism of action of pleuromutilin with ribosome. In this study, the overproducing phenotype in PL11 can be ascribed to a point mutation in the rplC and can be transferred to another high producer by genetic manipulation. Moreover, the resulting high-producing strains could be used as a starting strain to perform further ribosome engineering, as indicated where cumulative drug resistance mutations could dramatically enhance antibiotic production in Streptomyces.

5. Conclusion

In this paper, we examined the effect of pleuromutilin resistance on antibiotic production in Streptomyces. The results showed that mutants could increase the production of daptomycin by approximately 30%. Genetic analysis identified a novel G152V mutation site in L3 protein. Taken together, these results indicated that pleuromutilin can be used as a novel agent for ribosome engineering to enhance the production of secondary metabolites.

Acknowledgments

This work was supported by Grants from the Fundamental Research Funds for the Central Universities (XDJK2013B041) and the National Students Research Training Program (1229006).

References

R. D. Arbeit, D. Maki, F. P. Tally, E. Campanaro, and B. I. Eisenstein, “The safety and efficacy of daptomycin for the treatment of complicated skin and skin-structure infections,” Clinical Infectious Diseases, vol. 38, no. 12, pp. 1673–1681, 2004.

V. G. Fowler Jr., H. W. Boucher, G. R. Corey et al., “Daptomycin versus standard therapy for bacteremia and endocarditis caused by Staphylococcus aureus,” The New England Journal of Medicine, vol. 355, no. 7, pp. 653–665, 2006.

G. Iiao, T. Shi, and J. Xie, “Regulation mechanisms underlying the biosynthesis of daptomycin and related lipopeptides,” Journal of Cellular Biochemistry, vol. 113, no. 3, pp. 735–741, 2012.

G. Yu, X. Jia, J. Wen et al., “Strain improvement of Streptomyces roseosporus for daptomycin production by rational screening of He-Ne laser and NTG induced mutants and kinetic modeling,” Applied Biochemistry and Biotechnology, vol. 163, no. 6, pp. 729–743, 2011.

G. Liao, L. Wang, Q. Liu, F. Guan, Y. Huang, and C. Hu, “Manipulation of kynurenine pathway for enhanced daptomycin production in Streptomyces roseosporus,” Biotechnology Progress, 2013.

D. Huang, J. Wen, G. Wang, G. Yu, X. Jia, and Y. Chen, “In silico aided metabolic engineering of Streptomyces roseosporus for daptomycin yield improvement,” Applied Microbiology and Biotechnology, vol. 94, no. 3, pp. 637–649, 2012.

D. Huang, X. Jia, J. Wen et al., “Metabolic flux analysis and principal nodes identification for daptomycin production improvement by Streptomyces roseosporus,” Applied Biochemistry and Biotechnology, vol. 165, no. 7-8, pp. 1725–1739, 2011.

K. Ochi and T. Hosaka, “New strategies for drug discovery: activation of silent or weakly expressed microbial gene clusters,” Applied Microbiology and Biotechnology, vol. 97, no. 1, pp. 87–98, 2013.

G. Wang, T. Hosaka, and K. Ochi, “Dramatic activation of antibiotic production in Streptomyces coelicolor by cumulative drug resistance mutations,” Applied and Environmental Microbiology, vol. 74, no. 9, pp. 2834–2840, 2008.

K. Kurosawa, T. Hosaka, N. Tamehiro, T. Inaoka, and K. Ochi, “Improvement of α-amylase production by modulation of ribosomal component protein S12 in Bacillus subtilis 168,” Applied and Environmental Microbiology, vol. 72, no. 1, pp. 71–77, 2006.

K. Ochi, S. Okamoto, Y. Tozawa et al., “Ribosome engineering and secondary metabolite production,” Advances in Applied Microbiology, vol. 56, pp. 155–184, 2004.

Y. Tanaka, K. Kasahara, Y. Hirose, K. Murakami, R. Kugimiya, and K. Ochi, “Activation and products of the cryptic secondary metabolite biosynthetic gene clusters by rifampin resistance (rpoB) mutations in actinomycetes,” Journal of Bacteriology, vol. 195, no. 13, pp. 2959–2970, 2013.

L. Wang, Y. Zhao, Q. Liu, Y. Huang, C. Hu, and G. Liao, “Improvement of A21978C production in Streptomyces roseosporus by reporter-guided rpsL mutation selection,” Journal of Applied Microbiology, vol. 112, no. 6, pp. 1095–1101, 2012.

C. Hu and Y. Zou, “Mutilins derivatives: from veterinary to human-used antibiotics,” Mini-Reviews in Medicinal Chemistry, vol. 9, no. 12, pp. 1397–1406, 2009.

B. Malbruny, A. M. Werno, D. R. Murdoch, R. Leclercq, and V. Cattoir, “Cross-resistance to lincosamides, streptogramins A, and pleuromutilins due to the lsa(C) gene in Streptococcus agalactiae UCN70,” Antimicrobial Agents and Chemotherapy, vol. 55, no. 4, pp. 1470–1474, 2011.

B. B. Li, C. M. Wu, Y. Wang, and J. Z. Shen, “Single and dual mutations at positions 2058, 2503 and 2504 of 23s rRNA and their relationship to resistance to antibiotics that target the large ribosomal subunit,” Journal of Antimicrobial Chemotherapy, vol. 66, no. 9, pp. 1983–1986, 2011.

D. R. Gentry, S. F. Rittenhouse, L. McCloskey, and D. J. Holmes, “Stepwise exposure of Staphylococcus aureus to pleuromutilins is associated with stepwise acquisition of mutations in rplC and minimally affects susceptibility to retapamulin,” Antimicrobial Agents and Chemotherapy, vol. 51, no. 6, pp. 2048–2052, 2007.

M. Pringle, J. Poehlsgaard, B. Vester, and K. S. Long, “Mutations in ribosomal protein L3 and 23S ribosomal RNA at the peptidyl transferase centre are associated with reduced susceptibility to tiamulin in Brachyspira spp. isolates,” Molecular Microbiology, vol. 54, no. 5, pp. 1295–1306, 2004.

K. T. Nguyen, D. Kau, J. Q. Gu et al., “A glutamic acid 3-methyltransferase encoded by an accessory gene locus important for daptomycin biosynthesis in Streptomyces roseosporus,” Molecular Microbiology, vol. 61, no. 5, pp. 1294–1307, 2006.

L. Wang, X. Tian, J. Wang et al., “Autoregulation of antibiotic biosynthesis by binding of the end product to an atypical response regulator,” Proceedings of the National Academy of Sciences of the United States of America, vol. 106, no. 21, pp. 8617–8622, 2009.

Y. Pan, G. Liu, H. Yang, Y. Tian, and H. Tan, “The pleiotropic regulator AdpA-L directly controls the pathway-specific activator of nikkomycin biosynthesis in Streptomyces ansochromogenes,” Molecular Microbiology, vol. 72, no. 3, pp. 710–723, 2009.

V. Miao, M. F. Coeffet-Legal, P. Brian et al., “Daptomycin biosynthesis in Streptomyces roseosporus: cloning and analysis of the gene cluster and revision of peptide stereochemistry,” Microbiology, vol. 151, no. 5, pp. 1507–1523, 2005.

K. Ochi, “From microbial differentiation to ribosome engineering,” Bioscience, Biotechnology and Biochemistry, vol. 71, no. 6, pp. 1373–1386, 2007.

R. Novak, “Are pleuromutilin antibiotics finally fit for human use?” Annals of the New York Academy of Sciences, vol. 1241, no. 1, pp. 71–81, 2011.