BioMed Research International

Volume 2014 (2014), Article ID 138768, 8 pages

http://dx.doi.org/10.1155/2014/138768

Research Article

Degradation Potential of Protocatechuate 3,4-Dioxygenase from Crude Extract of Stenotrophomonas maltophilia Strain KB2 Immobilized in Calcium Alginate Hydrogels and on Glyoxyl Agarose

Urszula Guzik, Katarzyna Hupert-Kocurek, Marta Krysiak, and Danuta Wojcieszyńska

Department of Biochemistry, Faculty of Biology and Environmental Protection, University of Silesia in Katowice, Jagiellonska 28, 40-032 Katowice, Poland

Received 29 April 2013; Accepted 19 December 2013; Published 12 February 2014

Academic Editor: Petros Gikas

Copyright © 2014 Urszula Guzik et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract.

Microbial intradiol dioxygenases have been shown to have a great potential for bioremediation; however, their structure is sensitive to various environmental and chemical agents. Immobilization techniques allow for the improvement of enzyme properties. This is the first report on use of glyoxyl agarose and calcium alginate as matrixes for the immobilization of protocatechuate 3,4-dioxygenase. Multipoint attachment of the enzyme to the carrier caused maintenance of its initial activity during the 21 days. Immobilization of dioxygenase in calcium alginate or on glyoxyl agarose resulted in decrease in the optimum temperature by 5°C and 10°C, respectively. Entrapment of the enzyme in alginate gel shifted its optimum pH towards high-alkaline pH while immobilization of the enzyme on glyoxyl agarose did not influence pH profile of the enzyme. Protocatechuate 3,4-dioygenase immobilized in calcium alginate showed increased activity towards 2,5-dihydroxybenzoate, caffeic acid, 2,3-dihydroxybenzoate, and 3,5-dihydroxybenzoate. Slightly lower activity of the enzyme was observed after its immobilization on glyoxyl agarose. Entrapment of the enzyme in alginate gel protected it against chelators and aliphatic alcohols while its immobilization on glyoxyl agarose enhanced enzyme resistance to inactivation by metal ions.

1. Introduction

Protocatechuate 3,4-dioxygenase belongs to the iron-dependent enzymes and catalyzes intradiol cleavage of aromatic compounds [1]. The active site of this enzyme contains two tyrosines, two histidines, and a hydroxide ion as ligands of the high-spin iron(III) [2]. Interactions between substrate and atom of iron(III) cause activation of the substrate for an electrophilic attack by molecular oxygen. It leads to the peroxobridge formation between the iron and C4 of substrate. Next, Criegee rearrangement of this structure occurs, leading to the cyclic anhydride formation [1]. These enzymes take part in degradation of various aromatic compounds but they can be inhibited by different agents such as substrate analogues, chelators, and metal ions [3–7]. For that reason, identification and isolation of enzymes resistant to these factors have become an important subject of the research and are crucial for environment bioremediation. However, direct application of enzymes in environmental treatment technologies is limited due to the loss of enzymes’ activity [8]. Therefore, different methods of their stabilization have been developed. One of them is immobilization which has been used as a tool to improve many of enzymes’ properties such as operational stability, inhibitor resistance, and performance in organic solvents [8–10].

Calcium alginate gel is well known and the most widely used carrier in bioremediation process [9, 11]. It is nontoxic and inexpensive. Entrapment of enzymes in calcium alginate gel protects them against environmental factors such as pH, temperature, oxygen, organic solvent, or chelators, but has the drawback of mass transfer limitation and low enzyme loading [10, 12]. Better stabilization of the enzyme can be achieved by its multipoint attachment to the carrier since formation of additional covalent bonds increases the rigidity of the immobilized enzyme [13, 14]. Among different methods of multipoint covalent strategies, one of the most effective is immobilization on glyoxyl-agarose. In this method aldehyde groups of resin react with exposed primary amino groups of the enzyme [15, 16].

Protocatechuate 3,4-dioxygenase form Stenotrophomonas maltophilia KB2, which catalyzes nitrophenol, is highly resistant to metal ions [6, 7]. Because of high biotransformation potential of this enzyme, in this study we have attempted to improve its functional and thermal stability as well as resistance to inhibitors through noncovalent immobilization in calcium alginate hydrogel or multipoint covalent immobilization on glyoxyl-agarose.

2. Materials and Methods

2.1. Media and Culture Conditions

Stenotrophomonas maltophilia KB2 (VTT E-113197) was enriched in mineral salts medium (MSM), as described previously [7], in the presence of 6 mM 4-hydroxybenzoic acid. Cultures were incubated at 30°C and agitated at 130 rpm.

2.2. Preparation of Cell Extracts

Cells were harvested in the late exponential growth phase (after 15 hours) and centrifuged at 4,500 g for 15 min at 4°C. Next, the cells were washed with 50 mM phosphate buffer, pH 7.0, and resuspended in the same buffer. Cells were sonicated 6x for 15 s and centrifuged at 9,000 g for 30 min at 4°C. The supernatant was used as crude extract for enzyme assays and immobilization procedures.

2.3. Calcium Alginate Hydrogel Formation

For immobilization of protocatechuate 3,4-dioxygenase in calcium alginate, 3 mL of enzyme solution were suspended in 7 mL of 3% (w/v) sodium alginate in 50 mM phosphate buffer solution (pH 7.0) and homogenized. After homogenization the mixture was dropped into 25 mL of 0.15 M solution. Upon contact with the solution, drops were gelled to form constant and defined-sized spheres (external diameter 2.0 mm), which remained in the solution, under mild agitation, to complete the gel formation. After 1 h of incubation, the beads were removed by vacuum filtration, washed three times with phosphate buffer solution (pH 7.0), and stored at 4°C. Such prepared alginate beads were used to analyze properties of immobilized enzyme.

2.4. Immobilization of Protocatechuate 3,4-Dioxygenase on Glyoxyl Agarose

Immobilization of protocatechuate 3,4-dioxygenase on glyoxyl agarose was prepared as previously described [13]. 1 mL of glyoxyl agarose was mixed with 9 mL crude extract. The progress of the immobilization was monitored by measuring enzymatic activity until the activity measurements remained constant, which indicated complete immobilization. The resulting derivatives were reduced with sodium borohydride. After 30 minutes borohydride was eliminated by washing with 50 mM phosphate buffer (pH 7.0) and abundant distilled water.

2.5. Enzyme Assays

9 mM 4-hydroxybenzoate was used as the inducer of protocatechuate 3,4-dioxygenase. Specific activity of free and immobilized protocatechuate 3,4-dioxygenase was assayed by measuring oxygen consumption [6]. After the addition of the enzyme (in either free or immobilized form), vials were incubated at 30°C in water-bath with shaking. At regular time intervals (30 s), the reaction progress was monitored by measurements of oxygen consumption.

One unit of enzyme activity was defined as the amount of enzyme required to generate 1 moL of product per minute at 35°C. Activity of free and immobilized enzyme was expressed as specific activity (U/mg protein). The soluble and immobilized protein concentration was determined by the dye-binding procedure of Bradford using bovine serum albumin as a standard, as described previously [10].

2.6. pH and Temperature Optima of Free and Immobilized Protocatechuate 3,4-Dioxygenase

The effect of pH on the enzyme activity was determined by measuring the activity at 30°C over the pH range 2.2–10.0 using the following buffers: 0.05 M phosphate-citrate (pH 4.0 to 4.5), 0.05 M Sörensen (pH 5.0), 0.05 M phosphate (pH 5.7 to 8.0), 0.05 glycine (pH 10.0), 0.05 Britton-Robinson (pH 11.00 to 12.00), and 0.05 ammonia-sodium hydroxide (pH 13.00-14.00).

The optimum temperature was determined by assaying the enzyme activity at various temperatures (4 to 65°C) in 50 mM phosphate buffer solution (pH 7.4). The enzyme and the substrate solutions were preincubated, mixed, and followed by the enzymatic reaction at the same temperature.

2.7. Substrate Specificity

Impact of various substituted derivatives of aromatic compounds on activity of free and immobilized enzyme was evaluated by incubating the enzyme with the respective aromatic compound for 3 min and assaying the activity. As a substrate, aromatic dihydroxy acids: 2,3-; 2,4-; 2,5-; 2,6-; 3,5-dihydroxybenzoate, caffeic acid, and 3,4-dihydroxyhydrocinnamic acid at 1 mM concentration were used.

2.8. Activity of Enzyme in the Presence of Inhibitors

Impact of various aliphatic alcohols and chelators on both free and immobilized enzyme was evaluated by incubating the enzyme with the respective inhibitor for 3 min and then assaying the residual activity. At regular time intervals (30 s), reaction progress was monitored by measuring oxygen consumption. Assay of catechol 2,3-dioxygenase was proceeding in the same way as in the case of noninhibited. Aliphatic alcohols studied were methanol, ethanol, propanol, and butanol at 100 mM, 200 mM, and 300 mM concentrations. For inhibition studies EDTA, 2,2′-dipyridyl, and phenanthroline at 1 mM, 2 mM, and 3 mM concentrations were used.

3. Results and Discussion

3.1. Storage Stability

Protocatechuate 3,4-dioxygenase was immobilized in calcium alginate or on glyoxyl agarose. One of the most important parameters which should be considered during immobilization of enzyme is storage stability because of its practical application. The stability of free and the immobilized protocatechuate 3,4-dioxygenase was determined after storage of preparations in the phosphate buffers (50 mM, pH 7.0, for free enzyme or enzyme immobilized in calcium alginate and 40 mM, pH 8.0, for protocatechuate 3,4-dioxygenase immobilized on glyoxyl agarose) at 4°C for predetermined period. The entrapment of the protocatechuate 3,4-dioxygenase in calcium alginate matrix did not significantly influence the storage stability (Figure 1(a)). Multipoint attachment of the enzyme to the carrier (glyoxyl agarose) caused maintenance of its initial activity for a period of 21 days (Figure 1(b)). Moreover, immobilized enzyme still showed 9.93% of its initial activity after 28 days of storage, while activity of the free enzyme was not observed.

(a)

(b)

Figure 1: Storage stabilities of protocatechuate 3,4-dioxygenase from Stenotrophomonas maltophilia KB2 immobilized in calcium alginate (a) or on glyoxyl agarose (b). Data shown represent the average of three independent trials.

3.2. Influence of Enzyme Immobilization on pH and Temperature Optimum

Environmental factors affecting enzymatic reactions include temperature and pH. Determination of the influence of protocatechuate 3,4-dioxygenase immobilization on pH optimum showed that entrapment of the enzyme in calcium alginate gel shifted its optimum pH towards high-alkaline pH (Figure 2(a)). In contrast, immobilization of the enzyme on glyoxyl agarose did not influence its pH profile. However, immobilization of protocatechuate 3,4-dioxygenase on this carrier caused significant increase of its activity (Figure 2(b)). Comparison of the temperature-activity profiles (Figures 2(c) and 2(d)) showed that the enzyme immobilized either in calcium alginate or on glyoxyl agarose had approximately 5°C and 10°C lower optimum temperature than free enzyme. Additionally, higher activity of the enzyme immobilized on glyoxyl agarose was observed (Figure 2(d)). It may result from the formation of covalent bonds between the enzyme and the carrier and the increase of enzyme rigidity [17]. Similarly, higher activity of enzyme after its immobilization was observed by Singh and Ahmed [18] and Cristovao et al. [19].

(a)

(b)

(c)

(d)

Figure 2: Effects of pH ((a), (b)) and temperature ((c), (d)) on protocatechuate 3,4-dioxygenase from Stenotrophomonas maltophilia KB2 immobilized in calcium alginate ((a), (c)) or on glyoxyl agarose ((b), (d)). The data points represent the average of 3 independent experiments.

3.3. Effect of Immobilization on Substrate Specificity

Many of intradiol dioxygenases show narrow substrate specificity and regioselectivity [3, 20, 21]. These features make them attractive tools for biocatalytic production of fine chemical, pharmaceutical, or food ingredients. However, in bioremediation processes enzymes with wide substrate specificity are desirable.

Protocatechuate 3,4-dioxygenase from KB2 strain showed activity against various dihydroxybenzoic acids; however, its activity towards these compounds was lower than against primary substrate (protocatechuic acid). Immobilization of enzyme in both carriers increased its activity against all examined substrates (Table 1). Activity of the enzyme immobilized in calcium alginate increased particularly towards 2,5-dihydroxybenzoate, caffeic acid, 2,3-dihydroxybenzoate, and 3,5-dihydroxybenzoate. Caffeic acid and 3,4-dihydroxyhydrocinnamic acid possess the same configuration of hydroxyl group as protocatechuic acid. Immobilization of enzyme in calcium alginate increased its activity despite the presence of large substituent at 1 C position of substrate. Slightly lower activity of the enzyme was observed after its immobilization on glyoxyl agarose (Table 1). Higher activity of protocatechuate 3,4-dioxygenase toward ortho-diphenols with large substituents at the 4-position was observed by Hammer et al. [21]. This effect could be related to interactions between amino acid residues at the entrance into the active site and the carriers that extended area of substrate entrance. Various activities of enzyme towards tested substrates may also be connected with the type of matrix used for immobilization. Enzyme immobilized in calcium alginate gel binds to the carrier by electrostatic interaction while glyoxyl agarose is linked with the enzyme by covalent bonds. Since positively charged amino acids are localized at the entrance of crevasse, the electrostatic interaction plays the key role in modulation of enzyme activity [2, 22, 23]. Significant increase of enzyme activity after its immobilization in calcium alginate was probably caused by strong electrostatic interactions between positively charged amino acid residues of the enzyme and negatively charged groups of alginate.

Table 1: Substrate specificity of immobilized protocatechuate 3,4-dioxygenase from Stenotrophomonas maltophilia KB2. Data shown represent the average of three independent trials ± standard deviation.

Substrate
Relative activity of free enzyme, %
Relative activity of the enzyme immobilized in calcium alginate, %
Relative activity of the enzyme immobilized on glyoxyl agarose, %

Control-protocatechuate
100.0 ± 0.00
100.0 ± 0.00
100.0 ± 0.00

2,3-dihydroxybenzoate
23.60 ± 3.98
149.34 ± 22.94
119.83 ± 7.83

2,4-dihydroxybenzoate
43.50 ± 5.73
96.52 ± 16.78
65.60 ± 13.61

2,5-dihydroxybenzoate
33.46 ± 0.00
158.62 ± 11.71
72.11 ± 12.59

2,6-dihydroxybenzoate
30.51 ± 2.05
90.40 ± 6.09
36.15 ± 7.42

3,5-dihydroxybenzoate
44.33 ± 3.18
113.25 ± 2.81
42.86 ± 13.61

Caffeic acid
34.21 ± 9.65
150.00 ± 16.39
97.08 ± 11.13

3,4-dihydroxyhydrocinnamic acid
29.54 ± 5.42
95.03 ± 7.02
41.11 ± 15.26

Surprisingly, significant increase in activity of protocatechuate 3,4-dioxygenase immobilized in calcium alginate against 2,3-dihydroxybenzoate, 2,5-dihydroxybenzoate, and 3,5-dihydroxybenzoate (Table 1) was observed. These compounds are nontypical substrates for this enzyme because of hydroxyl group configuration. Each of the above-mentioned substrates possesses at least one hydroxyl group in meta position. High activity of immobilized protocatechuate 3,4-dioxygenase towards 2,3-dihydroxybenzoate, 2,5-dihydroxybenzoate, and 3,5-dihydroxybenzoate could be connected with modification of its catalytic mechanism as only 2,3-dihydroxybenzoate is in configuration typical for protocatechuate 3,4-dioxygenase's substrate. Complete change of enzyme activity after its immobilization was often observed. For example, urokinase immobilized on glyoxyl agarose showed activity of glutathione S-transferase or lipase after its immobilization in organic solvents catalysed transesterification reaction [14, 24].

3.4. Enzyme Activity in the Presence of Inhibitors

Inhibitors interact with specific regions of the enzyme and inhibit enzymes. For that reason immobilization may reduce inhibition in two different ways based on the type of inhibition. After immobilization allosteric site of enzyme may be blocked which makes interaction between this site and allosteric inhibitor impossible. Immobilization may also slightly deform enzyme structure and as a consequence influence changes in affinity of inhibitor to the active site of enzyme [14].

Protocatechuate 3,4-dioxygenase possesses an iron ion in the active site and therefore it was interesting to check the influence of aliphatic alcohols on enzyme activity after its immobilization. As it is known, aliphatic alcohols may coordinate metal ions and have an influence on the reaction microenvironment [1, 25, 26]. After immobilization of enzyme in calcium alginate we did not observe its inhibition by aliphatic alcohols at all tested concentration (Table 2). Only 0.3 mM methanol weakly inhibited examined enzyme. This effect is connected with small size of methanol molecule, which penetrates the extended entrance into the active site. Strong inhibition of enzymatic activity by aliphatic alcohols, especially methanol and ethanol, was observed after immobilization of protocatechuate 3,4-dioxygenase on glyoxyl agarose. Low molecular alcohols inhibited the examined enzyme after immobilization on glyoxyl agarose due to its strong hydrogen interaction with the enzyme in this environment [10, 26]. Changes in enzyme structure after its immobilization caused by covalent interaction made the enzyme more sensitive to aliphatic alcohols.

Table 2: Effect of aliphatic alcohols on the activity of immobilized protocatechuate 3,4-dioxygenase from Stenotrophomonas maltophilia KB2. Data shown represent the average of three independent trials ± standard deviation.

Compound
Concentration, (M)
Relative activity of free enzyme, %
Relative activity of the enzyme immobilized in calcium alginate, %
Relative activity of the enzyme immobilized on glyoxyl agarose, %

None

100.0 ± 0.00
100.0 ± 0.00
100.0 ± 0.00

Methanol
100
96.53 ± 0.54
110.70 ± 6.88
37.07 ± 17.47

200
91.53 ± 2.18
90.08 ± 2.48
45.17 ± 9.28

300
101.54 ± 2.18
74.71 ± 2.2
100.00 ± 13.65

Ethanol
100
144.61 ± 13.06
90.47 ± 3.58
67.18 ± 14.20

200
156.69 ± 3.81
116.54 ± 1.92
52.51 ± 5.46

300
141.92 ± 1.63
155.65 ± 22.01
50.58 ± 28.94

Propanol
100
160.78 ± 22.84
100.39 ± 4.40
93.82 ± 9.28

200
134.23 ± 5.98
101.75 ± 7.98
78.38 ± 8.19

300
130.38 ± 1.63
101.75 ± 4.13
76.83 ± 11.47

Butanol
100
112.69 ± 1.63
122.28 ± 0.83
108.49 ± 3.82

200
120.77 ± 2.18
118.10 ± 11.28
86.87 ± 30.03

300
120.38 ± 2.72
109.15 ± 20.64
76.44 ± 0.0

Protective effect of immobilization in calcium alginate on enzyme activity was observed in the presence of , , and while in the presence of and inhibitory effect of metals on enzyme activity increased (Table 3). Protocatechuate 3,4-dioxygenase activation in the presence of may be caused by greater availability of this ion for the active site. Untypical high activity of the enzyme in the presence of after entrapment of enzyme requires further research.

Table 3: Effect of metals on the activity of immobilized protocatechuate 3,4-dioxygenase from Stenotrophomonas maltophilia KB2. Data shown represent the average of three independent trials ± standard deviation.

Compound
Concentration, (mM)
Relative activity of free enzyme, % [6]
Relative activity of the enzyme immobilized in calcium alginate, %
Relative activity of the enzyme immobilized on glyoxyl agarose, %

None

100.0 ± 0.00
100.0 ± 0.00
100.0 ± 0.00

Co²⁺
1
74.34 ± 19.14
39.68 ± 8.98
61.65 ± 8.88

2
70.58 ± 8.45
70.63 ±7.86
67.27 ± 0.00

3
51.55 ± 4.70
97.62 ± 3.37
86.11 ± 9.82

Cu²⁺
1
41.81 ±4.07
30.16 ± 0.00
85.12 ± 0.00

2
27.36 ± 2.61
28.57 ± 2.24
80.16 ± 5.61

3
29.64 ± 0.63
22.22 ± 0.00
85.12 ± 0.00

Ni²⁺
1
78.65 ± 3.02
70.27 ± 0.00
69.58 ± 0.00

2
88.34 ± 2.29
84.24 ± 3.84
44.63 ± 10.05

3
83.85 ± 0.31
63.51 ± 11.47
59.67 ± 0.93

Mn²⁺
1
108.06 ± 8.19
50.40 ± 1.13
70.74 ± 0.70

2
98.55 ± 5.08
20.00 ± 3.39
75.87 ± 6.76

3
80.92 ± 5.43
29.60 ± 3.39
83.30 ± 2.10

Cd²⁺
1
69.33 ± 4.01
106.76 ± 7.64
84.70 ± 7.03

2
63.85 ± 2.13
115.54 ± 8.60
112.62 ± 6.49

3
60.20 ± 12.64
62.16 ± 3.82
93.12 ± 8.11

Al³⁺
1
89.99 ± 5.43
46.62 ± 10.51
87.76 ± 4.33

2
68.39 ± 3.21
83.11 ± 0.96
78.97 ± 9.19

3
33.50 ± 2.14
131.08 ± 11.47
91.20 ± 17.31

Zn²⁺
1
94.27 ± 7.21
27.20 ± 11.31
70.74 ± 0.70

2
71.79 ± 5.17
11.20 ± 6.79
82.97 ± 3.97

3
50.95 ± 2.76
4.80 ± 0.00
67.76 ± 9.58

Fe³⁺
1
38.93 ± 6.17
180.16 ± 19.08
61.50 ± 0.00

2
31.17 ± 6.08
150.79 ± 9.00
56.03 ± 6.54

3
22.76 ± 2.11
141.27 ± 6.73
54.38 ± 5.61

Immobilization of enzyme on glyoxyl agarose showed better protective effect than immobilization in calcium alginate (Table 3). Only in the presence of the inhibition increased. Nies [27] suggested that toxicity of is connected with tendency of this cation to bind to the cysteine or histidine residues of the protein. In the active site of intradiol dioxygenases, the iron is coordinated by two tyrosines and two histidines [1, 2]. Probably, the interaction between these residues and decreased enzyme activity after its immobilization [6, 27]. , , , and showed weaker effect on the enzyme activity (Table 3). Gopal et al. [28] demonstrated that ions of the same charge as the ions in the active site can replace them and in this way modulate enzyme activity. Since in the active site of protocatechuate 3,4-dioxygenase from KB2 ion is located, it could be replaced by . However, covalent immobilization of the enzyme increases its structure rigidity that makes the exchange of ions impossible. In our previous work we suggested that binding of transition metal ions such as , , , , or might deactivate enzyme by their interaction with the thiol groups of protocatechuate 3,4-dioxygenase [6]. The weaker inhibitory effect of and is connected with limited mobility of protein chain after its immobilization.

It is known that enzymes possessing metal ions at their active sites are sensitive to chelators [4, 29, 30]. Despite this, after immobilization of protocatechuate 3,4-dioxygenase from KB2 strain in calcium alginate gel, we did not observe inhibition of the enzyme in the presence of ferrous or ferric chelators (Table 4). Varga and Neujahr [31] observed correlation between substrate specificity and the strength of iron binding. However, our results show an opposite trend. After immobilization in calcium alginate gel protocatechuate 3,4-dioxygenase showed wide substrate specificity and the iron was strongly bind at the active site. In contrast protocatechuate 3,4-dioxygenases immobilized on glyoxyl agarose was inhibited by chelators at all tested concentrations (Table 4). Differences in the enzymatic behavior of protocatechuate 3,4-dioxygenases depending on the method of immobilization indicate various interactions between protein and the carrier.

Table 4: Effect of chelators on the activity of immobilized protocatechuate 3,4-dioxygenase from Stenotrophomonas maltophilia KB2. Data shown represent the average of three independent trials ± standard deviation.

Compound
Concentration, (M)
Relative activity of free enzyme, %
Relative activity of the enzyme immobilized in calcium alginate, %
Relative activity of the enzyme immobilized on glyoxyl agarose, %

None

100.0 ± 0.00
100.0 ± 0.00
100.0 ± 0.00

EDTA
100
135.07 ± 1.86
113.13 ± 7.11
46.72 ± 27.85

200
128.19 ± 23.46
97.54 ± 3.91
30.89 ± 6.55

300
18.19 ± 0.12
116.92 ± 8.35
32.43 ± 3.28

2,2′-dipyridyl
100
119.78 ± 0.87
123.81 ± 6.58
57.91 ± 0.00

200
99.30 ± 0.99
111.62 ± 3.55
30.12 ± 17.47

300
87.62 ± 4.85
117.40 ±3.56
22.01 ± 12.56

Phenanthroline
100
97.78 ± 7.33
117.53 ± 7.64
101.93 ± 1.09

150
81.46 ± 4.10
121.04 ± 5.87
60.62 ± 16.93

200
69.69 ± 3.11
101.56 ± 6.76
21.62 ± 7.64

4. Conclusions

Immobilization of protocatechuate 3,4-dioxygenase from Stenotrophomonas maltophilia KB2 has been shown to be an effective method for improving the substrate specificity of the enzyme. Differences in the enzyme behavior after immobilization in calcium alginate or on glyoxyl agarose resulted from the various types of interactions between the enzyme and the carrier. Entrapment of protocatechuate 3,4-dioxygenase protected the enzyme against chelators and aliphatic alcohols while covalent binding of the enzyme to the carrier caused its higher stability in the presence of metal ions. It should be emphasized that the differences in properties of the enzyme immobilized on glyoxyl agarose and in alginate may contribute to wider use of this enzyme in bioremediation. Production of biopreparat which contains the enzyme immobilized in different matrix seems to be the best way to improve degradation potential of protocatechuate 3,4-dioxygenase.

Conflict of Interests

All authors declare the absence of any conflict of interests including any financial, personal, or other relationships with other people or organizations that could inappropriately influence, or be perceived to influence, their work.

Acknowledgment

This work was supported by the Polish Ministry of Science and Higher Education (IP2010012170).

References

A. Wójcik, T. Borowski, and E. Broclawik, “The mechanism of the reaction of intradiol dioxygenase with hydroperoxy probe: a DFT study,” Catalysis Today, vol. 169, no. 1, pp. 207–216, 2011.

M. W. Vetting, D. A. D'Argenio, L. N. Ornston, and D. H. Ohlendorf, “Structure of Acinetobacter strain ADP1 protocatechuate 3,4-dioxygenase at 2.2 Å resolution: implications for the mechanism of an intradiol dioxygenase,” Biochemistry, vol. 39, no. 27, pp. 7943–7955, 2000.

C. T. Hou, M. O. Lillard, and R. D. Schwartz, “Protocatechuate 3,4-dioxygenase from Acinetobacter calcoaceticus,” Biochemistry, vol. 15, no. 3, pp. 582–588, 1976.

Y. P. Chen, M. J. Dilworth, and A. R. Glenn, “Aromatic metabolism in Rhizobium trifolii—protocatechuate 3,4-dioxygenase,” Archives of Microbiology, vol. 138, no. 3, pp. 187–190, 1984.

S. G. Iwagami, K. Yang, and J. Davies, “Characterization of the protocatechuic acid catabolic gene cluster from Streptomyces sp. strain 2065,” Applied and Environmental Microbiology, vol. 66, no. 4, pp. 1499–1508, 2000.

U. Guzik, K. Hupert-Kocurek, K. Sałek, and D. Wojcieszynska, “Influence of metal ions on bioremediation activity of protocatechuate 3,4-dioxygenase from Stenotrophomonas maltophilia KB2,” World Journal of Microbiology and Biotechnology, vol. 29, no. 2, pp. 267–273, 2013.

D. Wojcieszyńska, U. Guzik, I. Greń, M. Perkosz, and K. Hupert-Kocurek, “Induction of aromatic ring: cleavage dioxygenases in Stenotrophomonas maltophilia strain KB2 in cometabolic systems,” World Journal of Microbiology and Biotechnology, vol. 27, no. 4, pp. 805–811, 2011.

Y. Suma, D. Kim, J. W. Lee, et al., “Degradation of catechol by immobilized hydroxyquinol 1,2-dioxygenase (1,2-HQD) onto single-walled carbon nanotubes,” in Proceedings of the International Conference on Chemical, Environmental Science and Engineering (ICEEBS '12), Pattaya, Thailand, July 2012.

E. Kalogeris, Y. Sanakis, D. Mamma, P. Christakopoulos, D. Kekos, and H. Stamatis, “Properties of catechol 1,2-dioxygenase from Pseudomonas putida immobilized in calcium alginate hydrogels,” Enzyme and Microbial Technology, vol. 39, no. 5, pp. 1113–1121, 2006.

D. Wojcieszyńska, K. Hupert-Kocurek, A. Jankowska, et al., “Properties of catechol 2,3-dioxygenase from crude extract of Stenotrophomonas maltophilia strain KB2 immobilized in calcium alginate hydrogels,” Biochemical Engineering Journal, vol. 66, pp. 1–7, 2012.

A. Riaz, S. A. U. Qader, A. Anwar, and S. Iqbal, “Immobilization of a thermostable α-amylase on calcium alginate beads from Bacillus subtilis KIBGE-HAR,” Australian Journal of Basic and Applied Sciences, vol. 3, no. 3, pp. 2883–2887, 2009.

D. Brady and J. Jordaan, “Advances in enzyme immobilisation,” Biotechnology Letters, vol. 31, no. 11, pp. 1639–1650, 2009.

M. M. Yust, J. Pedroche, M. Alaiz et al., “Partial purification and immobilization/stabilization on highly activated glyoxyl-agarose supports of different proteases from flavourzyme,” Journal of Agricultural and Food Chemistry, vol. 55, no. 16, pp. 6503–6508, 2007.

R. K. Singh, M. K. Tiwari, R. Singh, and J. K. Lee, “From protein engineering to immobilization: promising strategies for the upgrade of industrial enzymes,” International Journal of Molecular Science, vol. 14, no. 1, pp. 1232–1277, 2013.

J. M. Bolivar, L. Wilson, S. A. Ferrarotti, J. M. Guisán, R. Fernández-Lafuente, and C. Mateo, “Improvement of the stability of alcohol dehydrogenase by covalent immobilization on glyoxyl-agarose,” Journal of Biotechnology, vol. 125, no. 1, pp. 85–94, 2006.

C. Megías, J. Pedroche, M. M. Yust et al., “Immobilization of angiotensin-converting enzyme on glyoxyl-agarose,” Journal of Agricultural and Food Chemistry, vol. 54, no. 13, pp. 4641–4645, 2006.

P. V. Iyer and L. Ananthanarayan, “Enzyme stability and stabilization—aqueous and non-aqueous environment,” Process Biochemistry, vol. 43, no. 10, pp. 1019–1032, 2008.

V. Singh and S. Ahmed, “Silver nanoparticle (AgNPs) doped gum acacia-gelatin-silica nanohybrid: an effective support for diastase immobilization,” International Journal of Biological Macromolecules, vol. 50, no. 2, pp. 353–361, 2012.

R. O. Cristovao, S. C. Silverio, A. P. M. Tavares et al., “Green coconut fiber: a novel carrier for the immobilization of commercial laccase by covalent attachment for textile dyes decolourization,” World Journal of Microbiology and Biotechnology, vol. 28, no. 9, pp. 2827–2838, 2012.

H. Fujisawa and O. Hayaishi, “Protocatechuate 3,4-dioxygenase. I. Crystallization and characterization,” The Journal of Biological Chemistry, vol. 243, no. 10, pp. 2673–2681, 1968.

A. Hammer, A. Stolz, and H. J. Knackmuss, “Purification and characterization of a novel type of protocatechuate 3,4-dioxygenase with the ability to oxidize 4-sulfocatechol,” Archives of Microbiology, vol. 166, no. 2, pp. 92–100, 1996.

C. Hartnett, E. L. Neidle, K. L. Ngai, and L. N. Ornston, “DNA sequences of genes encoding Acinetobacter calcoaceticus protocatechuate 3,4-dioxygenase: evidence indicating shuffling of genes and of DNA sequences within genes during their evolutionary divergence,” Journal of Bacteriology, vol. 172, no. 2, pp. 956–966, 1990.

A. M. Orville, N. Elango, J. D. Lipscomb, and D. H. Ohlendorf, “Structures of competitive inhibitor complexes of protocatechuate 3,4-dioxygenase: multiple exogenous ligand binding orientations within the active site,” Biochemistry, vol. 36, no. 33, pp. 10039–10051, 1997.

D. Rotticci, T. Norin, and K. Hult, “Mass transport limitations reduce the effective stereospecificity in enzyme-catalyzed kinetic resolution,” Organic Letters, vol. 2, no. 10, pp. 1373–1376, 2000.

I. Bertini, F. Briganti, and A. Scozzafava, “Aliphatic and aromatic inhibitors binding to the active site of catechol 2,3-dioxygenase from Pseudomonas putida mt-2,” FEBS Letters, vol. 343, no. 1, pp. 56–60, 1994.

A. Tezvergil-Mutluay, K. A. Agee, T. Hoshika et al., “Inhibition of MMPs by alcohols,” Dental Materials, vol. 27, no. 9, pp. 926–933, 2011.

D. H. Nies, “Microbial heavy-metal resistance,” Applied Microbiology and Biotechnology, vol. 51, no. 6, pp. 730–750, 1999.

B. Gopal, L. L. Madan, S. F. Betz, and A. A. Kossiakoff, “The crystal structure of a quercetin 2,3-dioxygenase from Bacillus subtilis suggests modulation of enzyme activity by a change in the metal ion at the active site(s),” Biochemistry, vol. 44, no. 1, pp. 193–201, 2005.

V. Gopalan, R. H. Glew, D. P. Libell, and J. J. DePetro, “The dual effects of alcohols on the kinetic properties of guinea pig liver cytosolic β-glucosidase,” The Journal of Biological Chemistry, vol. 264, no. 26, pp. 15418–15422, 1989.

U. Guzik, K. Hupert-Kocurek, and M. Sitnik, “High activity catechol 1,2-dioxygenase from Stenotrophomonas maltophilia KB2 as a useful tool in cis, cis-muconic acid production,” Antonie van Leeuwenhoek, vol. 103, no. 6, pp. 1297–1307, 2013.

J. M. Varga and H. Y. Neujahr, “Purification and properties of catechol 1,2-oxygenase from Trichosporon cutaneum,” European Journal of Biochemistry, vol. 12, no. 3, pp. 427–434, 1970.