Biotechnology Research InternationalVolume 2014 (2014), Article ID 642385, 10 pageshttp://dx.doi.org/10.1155/2014/642385

Research Article

Kojic Acid Production from Agro-Industrial By-Products Using Fungi

Ismael A. El-Kady,¹ Abdel Naser A. Zohri,¹ and Shimaa R. Hamed²

¹Botany Department, Faculty of Science, Assiut University, Assiut 71515, Egypt²Microbial Biotechnology Department, National Research Center, Dokki 12622, Egypt

Received 4 November 2013; Revised 4 February 2014; Accepted 4 February 2014; Published 23 March 2014

Academic Editor: Manuel Canovas

Copyright © 2014 Ismael A. El-Kady et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract.

A total of 278 different isolates of filamentous fungi were screened using synthetic medium for respective ability to produce kojic acid. Nineteen, six, and five isolates proved to be low, moderate, and high kojic acid producers, respectively. Levels of kojic acid produced were generally increased when shaking cultivation was used rather than those obtained using static cultivation. A trial for the utilization of 15 agro-industrial wastes or by-products for kojic acid production by the five selected higher kojic acid producer isolates was made. The best by-product medium recorded was molasses for kojic acid. A. flavus numbers 7 and 24 were able to grow and produce kojic acid on only 12 out of 15 wastes or by-products media. The best medium used for kojic acid production by A. flavus number 7 was rice fragments followed by molasses, while the best medium used for kojic acid production by A. flavus number 24 was the molasses followed by orange, pea, and rice fragments. An attempt for production of kojic acid using a 1.5 L laboratory fermentor has been made. Aspergillus flavus number 7 was used and grown on molasses medium; maximum level (53.5 g/L) of kojic acid was obtained after eight days of incubation.

1. Introduction

Kojic acid is a metabolic product of several species of the economically valuable genus Aspergillus. This mold is used in the production of a number of foods, including miso (soybean paste), shoyu (soy sauce), and sake, which are produced throughout the world. This mold is also used in the production of other fermented products including amazake (a sweet beverage), shochu (a distilled liquor), and mirin (a sweet, alcoholic seasoning), which are consumed primarily among the Japanese. Because kojic acid is produced during the fermentation of these historically used dietary staples, it has a long history of consumption. Health foods containing kojic acid are widely sold in Japan [1]. Kojic acid is permitted for addition to foods in Japan [2]. Kojic acid has been added to food as an antioxidant [3], as a preservative to prevent formation of warmed-over flavor in beef [4], as a processing aid to inhibit the formation of nitrosopyrrolidine in fried bacon [5], and to produce reddening in unripe strawberries [6]. It has also been used as a starting material for synthesis of the flavor enhancer’s maltol [7]. Yellow product formation takes place when both kojic acid and o-quinones are present. Kojic acid and some of its derivatives are used in cosmetic preparations to achieve a skin-lightening effect by inhibiting melanin formation and through a UV light protective action. Kojic acid also enhances shelf life of the product through its preservative actions against both chemical and microbial degradation [8, 9]. In addition, kojic acid has been used as an antibiotic, pesticide, and analytical chemical (in the determination of thorium and rare earths) as recorded by many investigator [10–12]. Utilization of industrial waste or by-products for the fungal production of useful products has been recommended by many investigations such as glycerol production by filamentous fungi using cheese whey [13–15], lipid, and sterol and ergosterol production by fungi using sugar cane molasses or cheese whey [16–18] and side-chain degradation and some biological transformation of progesterone by fungi using sugar cane molasses [19] and cyclosporin A production by fungi grown on agro-industrial wastes of some fruits, vegetables, and pickles as well as molasses and corn steeps [20–22]. The objective of this study was to study the following: the potentialities of kojic acid and production by 278 different fungal isolates; comparison between static and shaking cultivation methods for the production; optimization of both nutritional and environmental factors affecting the acid production; and utilization of 15 kinds of agro-industrial wastes or by-products by the high kojic acid producers for acid formation as well as production of this product on semi-industrial scale using a laboratory fermentor.

2. Materials and Methods

2.1. Tested Isolates

Two hundred and seventy-nine isolates of seventy-three species and one species variety represented sixteen genera of filamentous fungi collected during this study were examined for kojic acid production. These different isolates were obtained from the Botany Department, Faculty of science, Assiut University, Egypt, and AUMC (Assiut University Mycological Center), Assiut University.

2.2. Medium and Fermentation

The optimized medium for kojic acid production by A. flavus Link as proposed by Madiha et al. [23] was used in all experiments for inoculum preparation and also for kojic acid fermentation. The experimental cultures were grown in 250 mL Erlenmeyer flasks, each containing 50 mL of the synthetic medium. The flasks were sterilized at 121°C for 20 min and inoculated after cooling with 2 mL of 7- to 10-day-old cultures. The inoculum spore suspensions were prepared by adding sterile distilled water to the slant culture, followed by gentle agitation. The final concentration of spore’s suspension was about 5 × 10⁶ spores per mL. The cultures were incubated at 28 ± 2°C as stationary cultivation for 15 days.

2.3. Agro-Industrial Wastes and By-Products Used as Culture Media

(1) Fruits, Vegetables, and Pickle Wastes and Agriculture By-Products. Each individual fungal isolate of the highly kojic acid producers (five isolates) was cultivated on semisynthetic culture media. Each medium contained 100 g of agro-industrial waste product, individually, of each of orange, peach, apple, and apricot as fruit wastes; pea, mixed vegetable, and kidney beans as vegetables wastes; carrot and turnip as pickle wastes as well as wheat bran, rice fragments, and rice husk as agriculture by-products added to one liter of distilled water and supplemented with 5 g/L of yeast extract. All industrial wastes were collected from different juices, vegetables canning, and pickles factories located at the industrial areas of different governorates in Egypt, while the three agricultural by-products were collected from different farms of different governorates in Egypt.

(2) Corn Steep Liquor. Corn steeps liquor was prepared by using sweet corn maize. 100 g from the substrate was put in 2000 mL Erlenmeyer flasks and completed to 2000 mL by distilled water and cooked on a very quiet flame for 12 h; after that, these were filtered through a muslin cloth and used. Each individual fungal isolate of the highly kojic acid producers was cultivated on a medium consisting of 100 mL of corn steep liquor added to 900 mL of distilled water to complete one liter medium.

(3) Cheese Whey. Salted cheese whey is a by-product formed from milk during the production of cheese (both soft and hard cheese). Whey used during this work was produced from milk composed of 1 : 1 cow’s and buffalo’s milk which were used for production of white soft (Domiati type) cheese. Whey sample was kindly provided by Dairy Department, Faculty of Agricultural, Assiut University. Samples of whey (8% NaCl) were centrifuged (5000 rpm, 10 min), the sediment was discarded, and samples of supernatant were used as it is.

(4) Black-Strap Molasses. Black-strap molasses supplemented from El-Hawamdya sugar cane factory were tested as natural medium for cultivation of the experimental organisms. The molasses sample was centrifuged (5000 rpm, 10 min), the muddy sediment was discarded, and samples of supernatant were tested. Each individual fungal isolate of the highly kojic acid producers was cultivated on liquid semisynthetic medium of the following composition: supernatant molasses sample, 100 mL; yeast extract, 5.0 g; and completed to one liter distilled water. The pH of the different media was adjusted at 3.0 before sterilization. The cultures were incubated at 28 ± 2°C on rotary shaker (220 rpm) for 10 days.

2.4. Quantitative Determination of Kojic Acid

Kojic acid was determined using a spectrophotometric method with 2,6 dichlorophenolindophenol (DCIP) as recorded by Tanigaki et al. [7].

2.5. Production of Kojic Acid on Semi-Industrial Scale

A 1.5-liter B. Braun stirred tank (Biostat. A) fermentor (from B. Braun Biotech. International, Sortorius group, GmbH, Schwarzenberger, Germany) with one liter working volume was used in this study. The fermentor was equipped with pH, temperature, agitation, dissolved oxygen tension (DOT), and foam controllers. Seed cultures were carried out in 250 mL flask containing 50 mL of medium, held on a rotary shaker at 150 rpm, at 28°C for 48 h. Seed culture flask (50 mL) from fungal isolates (Aspergillus flavus number 7), which proved to be the higher kojic acid producer, was used to inoculate the fermentor at 30°C. Fermentation lasted around 14 days. The culture medium was modified synthetic medium consisting of (g/L): glucose, 100; yeast extract, 5.0; KH₂PO₄, 1.5; and MgSO₄·7H₂O, 0.5. The pH was adjusted to 3.0, temperature at 30°C, and agitation at 400 rpm, while the DOT in the culture broth was controlled via a sequential cascade control as air flow rate. The maximum and minimum set points of permitted airflow rates were 1.2 L/min and 0.1 L/min, respectively. The DOT during fermentation was controlled at medium (~50%) of saturation.

3. Results and Discussion

Screening the abilities of 278 different fungal isolates belonging to 16 genera and 71 species in addition to one species variety for kojic acid production was an aim in this study. Aspergillus was represented by 135 isolates of 18 species and one variety belonging to nine sections (Table 1). High concentrations (more than 15 g/L medium) of kojic acid were produced by only three isolates of A. flavus (numbers 7, 23, and 24) and two isolates of A. flavus var. columnaris (numbers 36 and 41). Moderate levels (5 to 15 g/L medium) were obtained by five Aspergillus isolates (one of each of A. flavus var. columnaris, number 39; A. terreus, number 131, and A. versicolor, number 143 in addition to two isolates of A. tamarii (numbers 129 and 130), while low concentrations (less than 5 g/L medium) were obtained by eight Aspergillus isolates as follows: three isolates of A. flavus (numbers 4, 9, and 32), two of A. phoenicis (numbers 119 and 120) in addition to one isolate of each of A. sclerotiorum (number 121), A. flavus var. columnaris (number 43), and A. wentii (number 145). It is worth mentioning that 12 out of the 18 Aspergillus isolates, which recorded as kojic acid producers, belonging to two species (A. flavus and A. tamarii) and one species variety (A. flavus var. columnaris) of section flavi (Table 1). Also, one isolate of each of Emericella nidulans (number 148) and Eurotium amstelodami (number 155) as species belonging to Aspergillus related genera (based on anamorph/teleomorph) had the ability to produce low levels of kojic acid. Kharchenko [24] studied the ability of 98 strains of A. flavus to form kojic acid and recorded 14 strains of them as highly active. This is nearly similar to those recorded in the present investigation (three out of 29 isolates tested of A. flavus were recorded as highly producers). Previously, several species of Aspergillus were recorded as kojic acid producers such as A. flavus [25–31], A. oryzae [32, 33], A. fumigatus [28, 34, 35], A. candidus, [33, 36], A. awamori, A. clavatus., A. ustus, and A. wentii [33]. Also, Manabe et al. [33] recorded A. nidulans (=anamorph of Emericella nidulans) as kojic acid producer. Parrish et al. [37], examined the production of kojic acid by 14 species of Aspergillus and recorded the production of the acid by each of A. clavatus, A. flavus, A. fumigates, A.oryzae, A. parasiticus, A. tamarii, A. ustus, and A. nidulans (=Emericella nidulans). Production of kojic acid by A. flavus var. columnaris, A. terreus, A. versicolor, A. phoenicis, A. sclerotiorum, and Eurotium amstelodami recorded in this study for first time, according to the available literatures.

Table 1: Production of kojic acid by different isolates belonging to various species and varieties of Aspergillus and their teleomorph.

Organisms
Code number
Total isolates tested
−ve isolates
+ve isolates

Low*
Moderate**
High***

Subgenus: circumdati

    Section: candidi

        A. Candidus Link
2
1
1
—
—
—

    Section: circumdati

        A. melleus Yukowa
78–80
3
3
—
—
—

        A. Ochraceus Wilhelm
100–113
14
14
—
—
—

        A. sclerotiorum Hoper
121
1
—
1
—
—

        A. Sulphureus (Fres.) Thom and Church
122, 123
2
2
—
—
—

    Section: Flavi

        A. flavus Link
4–32
29
23
3
—
3

        A. flavus var. columnaris Raper and Fennell
36–63
28
25
1
1
2

        A. Oryzae (Ahlburg) Cohn
115, 116
2
2
—
—
—

        A. Parasiticus Spear
117, 118
2
2
—
—
—

        A. tamarii Kita
129, 130
2
—
—
2
—

    Section: Nigri

        A. aculeatus Lizuka
1
1
1
—
—
—

        A. niger van Tieghem
81–99
19
19
—
—
—

        A. phoenicis (Cda.) Thom
119, 120
2
—
2
—
—

    Section: wentii

        A. wentii Wehmer
144–146
3
2
1
—
—

Subgenus: fumigati

    Section: Fumigati

        A. fumigatus Fresenius
64–75
12
12
—
—
—

Subgenus: Nidulantes

    Section: Flavipedes

        A. flavipes (Bain. and Sart) Thom and Church
3
1
1
—
—
—

    Section: Terii

        A. terreus Thom
131–139
9
8
—
1
—

    Section: Versicolores

        A. Janus Raper and Thom
77
1
1
—
—
—

        A. sydowii (Bain. and Sart) Thom and Church
124–127
4
4
—
—
—

        A. versicolor (Vuill.) Tiraboschi
143
1
—
—
1
—

Emericella nidulans (Eidam) Vuillemin
147–150
4
3
1
—
—

Eurotium amstelodami Mangin
151
1
—
1
—
5

Total
—
142
122
10
5
5

Less than 5 g/L medium kojic acid.

**5–15 g/L medium kojic acid.

***More than 5 g/L medium kojic acid.

Seventy-six isolates of 24 species of Penicillium belonging to four subgenera were tested for respective abilities to produce kojic acid (Table 2). Only one isolate of each of P. spinulosum (number 230), P. janthinellum (number 216), P. aurantiogriseum (number 154), P. frequentans (number 211), and P. godlewski (number 214) had the ability to produce kojic acid at low concentrations (less than 5 g/L medium). Ariff et al. [31] and Burdock et al. [38] reported that kojic acid could be produced by many species of Aspergillus and Penicillium. Parrish et al. [37] tested eight species of Penicillium for kojic acid production and found that each of P. puberulum, P. estmogenum, P. albidum, and P. daleae had the ability to produce kojic acid. Production of kojic acid by P. citrinum, P. griseofulvum, P. rubrum, and P. purpurogenum was previously recorded by Manabe et al. [33].

Table 2: Production of kojic acid by different isolates belonging to various species of Penicillium.

Organisms
Code number
Total isolates tested
−ve isolates
+ve isolates

Low*
Moderate**
High***

Subgenus:  aspergilloides

    P. Capsulatum Raper and Fennell
159-163
5
5
—
—
—

    P. lividum Westling
218–220
3
3
—
—
—

    P. spinulosum Thom
230, 231
2
1
1
—
—

Subgenus: biverticillium

    P. funiculosum Thom
213
1
1
—
—
—

    P. purpurogenum Stoll
227, 228
2
2
—
—
—

    P. rugulosum Thom
229
1
1
—
—
—

Subgenus: furactum

    P. citrinum Thom
187–201
15
15
—
—
—

    P. corylophilum Dierckx
202, 203
2
2
—
—
—

    P. herquei Bain. and Sart.
215
1
1
—
—
—

    P. janthinellum Biourge
216, 217
2
1
1
—
—

Subgenus: penicillium

    P. albidum Sopp
152
1
1
—
—
—

    P. atramentosum Thom
153
1
1
—
—
—

    P. aurantiogriseum Dierckx
154
1
—
1
—
—

    P. camemberti Thom
156, 157
2
2
—
—
—

    P. chrysogenum Thom
164–185
22
22
—
—
—

    P. cyaneofulvum Biourge
205
1
1
—
—
—

    P. cyclopium Westling
206
1
1
—
—
—

    P. digitatum (Pers. ex Fr.) Saccardo
207
1
1
—
—
—

    P. expansum Link ex Gray
210
1
1
—
—
—

    P. frequentans Westling
211, 212
2
1
1
—
—

    P. godlewski Zaleski
214
1
—
1
—
—

    P. nigricans (Bain.) Thom
222–226
5
5
—
—
—

    P. somniferum Thom
234
2
2
—
—
—

    P. viridicatum Westling
236
1
1
—
—
—

Total
—
76
71
5
—
—

Less than 5 g/L medium kojic acid.

**5–15 g/L medium kojic acid.

***More than 5 g/L medium kojic acid.

From 60 isolates belonging to 27 species of 12 genera representing Hyphomycetes (22 species of 9 genera) and Zygomycetes (five species of three genera) were tested for kojic acid production. Only one isolate of each of Fusarium equiseti number 271 (teleomorph: Gibberella intricans), F. moniliforme number 283 (teleomorph: G. fujikuroi), F. oxysporum number 287, F. tricinctum number 299, and Chaetomium globosum number 242 proved to be producers of kojic acid at low or moderate levels (Table 3). All these producers belonged to Hyphomycetes while all the tested isolates of Zygomycetes completely failed to produce any detectable amounts of kojic acid. According to the available literatures, there is no record on the production of kojic acid by any members of Hyphomycetes or Zygomycetes. The higher producer isolates of kojic acid (A. flavus numbers 7, 23, and 24 and A. flavus var. columnaris numbers 36 and 41) were selected for comparison between static and shaking cultivation methods. Generally, the concentrations of kojic acid produced were increased when submerged cultivation (shaking) was used than those recorded using surface cultivation (static) (Table 4). Kojic acid levels produced by the five isolates grown using shaking cultivation were fluctuated between 18.3 and 34.4 g/L medium, while those levels recorded using static cultivation ranged from 16.3 to 21.4 g/L medium. The high concentration of kojic acid (34.4 g/L) was formed by A. flavus number 7 using shaking cultivation. Nearly similar results were recorded by Ariff et al. [31]. They found that the level of kojic acid accumulated by A. flavus strain 44-1 using rotary shaker was 32.5 g/L. Rosfarizan and Ariff [39] found that the highest level of kojic acid production by A. flavus strain 44-1 reached 39.9 g/L in submerged batch fermentation.

Table 3: Production of kojic acid by different isolates belonging to Hyphomycetes and Zygomycetes.

Organisms
Code number
Total isolates tested
−ve isolates
+ve isolates

Low*
Moderate**
High***

Group: Hyphomycetes

    Family: Dematiaceae

        Alternaria alternata (Fries.) Keister
239–241
3
3
—
—
—

        Chaetomium globosum Kunze
242
1
—
1
—
—

        Pleospora herbarum (Fr.) Robenh. Exces. and De Notaris
247
1
1
—
—
—

        Scopulariopsis brevicaulis (Saccardo) Bainier
248
1
1
—
—
—

        Stachybotrys chartarum (Ehrenberg) Hughes
250, 251
2
2
—
—
—

        Stachybotrys theobromae Hansf.
252
1
1
—
—
—

        Torula herbarum (Pres.) Link
254
1
1
—
—
—

        Trichoderma hamatum (Bon.) Bain.
255
1
1
—
—
—

        T. koningii Oudemans
258
1
1
—
—
—

        T. longibrachiatum Rifai
259
1
1
—
—
—

        T. polysporum (Link ex pres.) Rifai
262, 263
2
2
—
—
—

    Family: Moniliaceae

        Acremonium strictum W. Gams
237
1
—
—
—
—

    Family: Tuberculariaceae

        Fusarium aquaeductuum (Radlk. and Rabenh.)
266
1
1
—
—
—

        F. chlamydosporum Wollenw. and Reinking
267–269
3
3
—
—
—

        F. equiseti (Corda) Saccardo
270, 271
2
1
1
—
—

        F. lateritium Nees and Sys.
272
1
1
—
—
—

        F. moniliforme Sheldon
273–283
11
10
1
—
—

        F. oxysporum Schlecht
284–295
12
11
—
1
—

        F. proliferatum (Matsushima) Nirenberg
296
1
1
—
—
—

        F. solani (Mart.) Saccardo
297
1
1
—
—
—

        F. subglutinans (Wollenw. and Reinking) Nelson
298
1
1
—
—
—

        F. tricinctum (Corda) Saccardo
299
1
—
—
—
—

Group: Zygomycetes

    Family: Mucoraceae

        Cunninghamella echinulata (Thaxter) Thaxt. ex Blakasles
315
1
1
1
—
—

        C. elegans Landner
316, 317
2
2
—
—
—

        Mucor Circinelliodes van Tieghem
319–321
3
3
—
—
—

        M. fuscus Bainier
329, 331, 332
3
3
—
—
—

    Family: Syncephalastraceae

        Syncephalastrum racemosum Cohn and Schroter
343
1
1
—
—
—

Total
—
60
55
4
1
—

Less than 5 g/L medium kojic acid.

**5–15 g/L medium kojic acid.

***More than 5 g/L medium kojic acid.

Table 4: Comparison between surface (static) and submerged (shaking) cultivation for kojic acid production (g/L) using the synthetic medium by the five highly producer organisms.

Organisms
Code number
Static cultivation
Shaking cultivation

Aspergillus flavus
24
16.3
18.3

A. flavus
23
18.5
28.5

A. flavus
7
21.4
34.4

A. flavus var.  columnaris
36
21.4
22.8

A. flavus var. columnaris
41
15.3
26.3

Manabe et al. [32] produced kojic acid at 40 mg/mL medium (=40 g/L) A. flavus isolated from Japanese fermented foods. El-Kady et al. [35] recorded 57–59 mg of kojic acid per mL medium formed by A. fumigatus isolated from Buffalo pneumonia. High concentration of kojic acid (60 g/L medium) was recorded by El-Sharkawy [30] using calcium alginate immobilization technique for kojic acid production by A. flavus ATCC 9179. Kwak and Rhee [40] produced kojic acid using, also, immobilized cells of A. oryzae and recorded a very high kojic acid production level (reached up to 80 g/L) in repeated batch culture. Higher final concentrations of kojic acid in solution caused kojic acid to crystallize in the form of fine needles [9, 40] and this is very useful for easy and low cost recovery. On the other hand, low level of kojic acid was recorded by Ogawa et al. [41], who reported that the maximum yield of kojic acid was around 20 mg/mL formed by A. oryzae NRRL 484 using shaking culture. Wakisaka et al. [42] found that the kojic acid level produced by A. oryzae NRRL 484 the same isolate used by Ogawa et al. [41] using shaking flask cultures was 24 g/L. The superior isolate (A. flavus Number 7) for kojic acid production (which formed 34.4 g/L of kojic acid using shaking cultivation) was selected, using this cultivation method for a series of experiments to determine the effect of some nutritional and environmental conditions on the efficiency of kojic acid production by this isolate. This is for maximization of kojic acid production. This study explained that optimal nutritional conditions for this isolate were 100 g/L glucose, 5.0 g/L yeast extract, and 1.5 g/L KH₂PO₄ as carbon, nitrogen, and phosphorus sources, respectively. The optimal pH, temperature, and incubation period as environmental conditions were pH 3, 30°C, and 10 days, respectively. These results are completely similar to those recorded by several investigators [31, 39, 43, 44]. An attempt has been made, in this study, to investigate the possibility to utilization of agro-industrial wastes or by-products as natural medium for kojic acid production by the five high producer isolates (A. flavus numbers 7, 23, and 24 and A. flavus var. columnaris numbers 36 and 41). The agro-industrial wastes and by-products used in this study were pea, kidney bean, and mixed vegetables wastes; the wastes of juice production of each of apple, apricot, orange, and peach; the wastes of other vegetables used as pickles, namely, carrot and turnip; three industrial by-products, namely, corn steep liquor, molasses, and cheese whey; in addition to three agricultural by-products as wheat bran, rice husk, and rice fragments (Tables 5, 6, and 7). Generally, kojic acid production levels by the five tested fungal isolates grown on any wastes or by-products under investigation were relatively low (ranged from 0.0 to 21.2 g/L medium) comparing to those levels produced by the same fungal isolates on synthetic medium which ranged from 18.3 to 34.4 g/L medium. Low levels of kojic acid production by the high producer isolates grew on a medium containing carbon sources other than glucose were previously recorded [39, 44, 45]. Rosfarizan and Ariff [39] reported that the level of kojic acid production by A. flavus strain 44-1 was 4.4 g/L in submerged batch fermentation using lactose as carbon source. Also, they reported that glucose was the best out of seven carbon sources tested (glucose, xylose, sucrose, fructose, lactose, maltose, and starch) for kojic acid production. Rosfarizan et al. [44] found that the maximum yield of kojic acid by A. flavus strain 44-1 grown on gelatinized sago starch as carbon source was 4.51 g/L. Moreover, no kojic acid was produced by A. oryzae when starch was used as carbon source as recorded by Kitada et al. [43]. Rice fragments and molasses as by-products were relatively suitable substrates, for kojic acid production by the five fungal isolates tested. The two tested isolates of A. flavus var. columnaris (numbers 36 and 41) in addition to one isolate of A. flavus (number 7) could use rice fragments as by-product medium and produce relatively high levels of kojic acid (21.2, 18.2 and 12.1 g/L, resp.), while the other two isolates tested of A. flavus (numbers 23 and 24) formed relatively high levels of the acid (9.3 and 5.1 g/L, resp.) on molasses medium (Table 7).

Table 5: Production of kojic acid (g/L) by the selected five highly producer organisms grown on vegetables and pickles wastes as well as synthetic media for 10 days as shaking cultivation.

Fungal isolates tested
Code number
Synthetic medium
Kind of vegetable wastes
Kind of pickles wastes

Pea
Kidney bean
Mixed vegetable
Carrot
Turnip

Control*
—
—
—
—
—
—
—

Aspergillus flavus
24
18.3
5.5
0.4
0.8
0.0
1.5

A. flavus
23
28.5
2.1
0.1
0.3
0.6
0.5

A. flavus
7
34.4
2.5
0.8
0.2
0.0
0.6

A. flavus var. columnaris
36
22.8
1.1
2.0
0.2
0.0
0.9

A. flavus var. columnaris
41
26.3
0.9
0.1
1.0
0.0
1.6

Control: wastes or by-products without fungal inoculum.

Table 6: Production of kojic acid (g/L) by the selected five highly producer organisms grown on fruit wastes as well as synthetic media for 10 days as shaking cultivation.

Fungal isolates tested
Code number
Synthetic medium
Kind of fruit wastes

Apple
Apricot
Orange
Peach

Control*
—
—
—
—
—
—

Aspergillus flavus
24
18.3
2.6
3.1
5.9
2.7

A. flavus
23
28.5
4.2
1.5
4.1
0.5

A. flavus
7
34.4
2.2
1.2
2.0
1.0

A. flavus var. columnaris
36
22.8
0.9
0.4
1.3
0.6

A. flavus var. columnaris
41
26.3
2.1
0.6
0.8
0.7

Control: wastes or by-products without fungal inoculum.

Table 7: Production of kojic acid (g/L) by the selected five highly producer organisms grown on agriculture and industrial by-products as well as synthetic media for 10 days as shaking cultivation.

Fungal isolates tested
Code number
Synthetic medium
Kind of agriculture by-products
Kind of industrial by-products

Wheat bran
Rice fragment
Rice husk
Corn steep liquor
Molasses
Whey

Control*
—
—
—
—
—
—
—
—

Aspergillus flavus
24
18.3
3.0
5.3
2.8
0.0
9.3
0.0

A. flavus
23
28.5
1.0
0.9
0.1
1.3
5.1
0.1

A. flavus
7
34.4
0.7
12.1
0.1
0.0
6.2
0.0

A. flavus var. columnaris
36
22.8
2.0
21.2
0.1
3.1
4.0
0.0

A. flavus var. columnaris
41
26.3
1.6
18.2
1.6
0.4
3.7
0.0

Control: wastes or by-products without fungal inoculum.

Egyptian sugar cane molasses contain about 44% as total sugar (glucose, sucrose, and fructose), 0.46% as total nitrogen in addition to detectable amounts of some vitamins such as riboflavin and thiamin [46, 47]. Lai et al. [48] reported that the main chemical characteristics of rice husk contain: carbon (45.3%), hydrogen (5.5%), nitrogen (0.67%), sulfur (0.29%), and chlorine (0.29) in addition to detectable amounts of potassium (1630 ppm), calcium (94 ppm), iron (202 ppm), sodium (207 ppm), zinc (24 ppm), magnesium (699), phosphorus (94 ppm), and other. Presence of these compounds in each of molasses and rice husk may favor kojic acid production. El-Refai and El-kady [49] and Ghanem et al. [50] reported the possible utilization of molasses for sterols production by yeast and filamentous fungi, respectively. Kahraman and Yesilada [51] used industrial and agricultural wastes as substrates for laccase production by Coriolus versicolor ATCC 200801 and Funalia trogii ATCC 200800 as white rot fungi and recommended using these waste in the production of important lignocellulolytic and other biotechnological enzymes, respectively. Sallam et al. [52] used a medium composed of cane sugar molasses (3%) and corn steep liquor (1%) for cyclosporin A (which used as a powerful immunosuppressant to prevent graft rejection in transplantation surgery) production by A. terreus and recorded the production of 45.23 mg cyclosporin A per each one liter medium. More recently, Ragaa Kotby [20] found that ten fungal isolates (one of each of A. ustus, Fusarium nivale, F. oxysporum, F. moniliforme, Trichoderma hamatum, and T. pseudokoningii in addition to four isolates of T. harzianum) had the ability to grow well and produce cyclosporin A at levels fluctuated between 400 and 1200 μg/50 mL of 10% molasses medium.

Production of kojic acid by the superior producer isolate (A. flavus number 7), recorded in this study, grew on the synthetic medium using a 1.5 laboratory fermentor (semi-industrial scale) was the target in the last experiment of this part in this investigation (Table 8). The results revealed that at the first two days, kojic acid concentration reached 28.6 g/L. After this time, kojic acid levels were increased gradually with the increase of fermentation time and reaching maximum level (53.5 g/L) after eight days of inoculation. Gradual decrease in kojic acid concentrations was recorded with further extension of fermentation period. These results are in harmony with that previously obtained by Ariff et al. [31]. They used a fermentor (2 L B, Braum stirred tank fermentor, Biostat. B) For kojic acid production by A. flavus strain 44-1 and found that kojic acid concentration reached up to 36.5 g/L after 11 days. Also, reduction of kojic acid formation after the concentration became maximum was observed by Ariff et al. [31] and El-Assar [53]. They attribute this reduction to degradation of kojic acid to oxalic and acetic acid by the mycelium under glucose depleted conditions [23, 31, 54, 55]. Futamura et al. [56] produced kojic acid by A. oryzae MK-107-39 in a jar fermentor and recorded that level of kojic acid reached up to 40 g/L. On the other hand, Wakisaka et al. [42] produced kojic acid by A. oryzae NRRL 484 using continuous membrane surface liquid culture technique and recorded that kojic acid concentration reached 45 mg/mL medium and nearly constant after 15 days of cultivation for over 70 days.

Table 8: Production of kojic acid (g/L) by the selected five highly producer isolate (A. flavus number 7) grown on the synthetic medium for 14 days using a laboratory fermentor.

Fermentation period (days)
Kojic acid (g/L)

2
28.6

4
31.5

6
48.3

8
53.5

10
51.6

12
50.8

14
47.1

In view of the wide use of kojic acid as a food ingredient (flavor enhancers, antioxidant, and/or discoloration) [57, 58], skin-lightening agent in cosmetic or dermatological preparations [22, 59], bacterial inhibitor, pain Killer, and anti-inflammatory agent in medical field [60], preventer for the undesirable melanosis (blackening) of agricultural products [45, 61] and many other uses, it seemed necessary to conduct a thorough investigation of production of kojic acid on large scale.

Conflict of Interests

The authors declare that they have no conflict of interests regarding the publication of this paper.

References

Y. Niwa and H. Akamatsu, “Kojic acid scavenges free radicals while potentiating leukocyte functions including free radical generation,” Inflammation, vol. 15, no. 4, pp. 303–315, 1991.

List of Food Additives Other Than Chemical Synthetics, notification no. 207, Ministry of Health and Welfare, Tokyo, Japan, 1989.

F. C. Wehner, P. G. Thiel, S. J. van Rensburg, and I. P. C. Demasius, “Tested on chicken embryos,” Toxicology Letters, vol. 13, pp. 239–245, 1978.

A. J. St. Angelo, J. R. Vercellotti, H. P. Dupuy, and A. M. Spanier, “Assessment of beef flavor quality, a multidisciplinary approach,” Food Technology, vol. 42, pp. 133–138, 1988.

R. F. Theiler, K. Sato, T. G. Aspelund, and A. F. Miller, “Inhibition of N-nitrosamine formation in a cured ground pork belly model system,” Journal of Food Science, vol. 49, no. 2, pp. 341–344, 1984.

P. J. Curtis, “Chemical introduction of local reddening in strawberry fruits,” Journal of the Science of Food and Agriculture, vol. 28, pp. 243–246, 1977.

H. Tanigaki, H. Obata, and T. Tokuyama, “The determination of kojic acid using the stopped-flow method,” Bulletin of the Chemical Society of Japan, vol. 35, pp. 3195–3197, 1980.

M. Uher, J. Brtko, O. Rajniakova, M. Kovac, and E. Novotana, “Kojic acid and its derivatives in cosmetics and health protection,” Parfuem-Kosmetik, vol. 74, pp. 554–556, 1993.

M. Rosfarizan, S. M. Mohd, S. Nurashikin, M. S. Madihah, and B. A. Arbakariya, “Kojic acid: applications and development of fermentation process for production,” Biotechnology and Molecular Biology Reviews, vol. 5, no. 2, pp. 24–37, 2010.

R. L. Beard and G. S. Walton, “Kojic acid as an insecticidal mycotoxin,” Journal of Invertebrate Pathology, vol. 14, no. 1, pp. 53–59, 1969.

S. Y. Shetty and R. M. Sathe, “Sequential determination of thorium and rare earths with EDTA and kojic acid,” Talanta, vol. 23, no. 1, pp. 46–47, 1976.

F. C. Wehner, P. G. Thiel, S. J. van Rensburg, and I. P. C. Demasius, “Mutagenicity to Salmonella typhimurium of some Aspergillus and Penicillium mycotoxins,” Mutation Research, vol. 58, no. 2-3, pp. 193–203, 1978.

I. A. El-kady, M. H. Moubasher, and M. Eman Mostafa, “Glycerol production by two filamentous fungi grown at different ionic and monionic osmotics and cheese whey,” Folia Microbiologica, vol. 39, no. 3, pp. 203–207, 1994.

A. A. Zohri, “Glycerol production from cheese whey by selected fungal cultures,” Journal of Food Science and Technology, vol. 37, no. 5, pp. 533–538, 2000.

N. R. Khamaruddin, M. Basri, G. E. C. Lian et al., “Enzymatic synthesis and characterization of palm-based kojic acid ester,” Journal of Oil Palm Research, vol. 20, pp. 461–469, 2008.

I. A. El-kady, A. A. Zohri, E. M. Mostafa, and S. M. Ragaa, “Lipid and sterol production by moulds on sugar can molasses by products,” in Proceeding of the 1st International Conference on Fungi: Hopes and Challenges, vol. 1, pp. 87–98, Al-Azhar University, Cairo, Egypt, September 1996.

E. M. Mostafa and A. A. Zohri, “Utilization of sugar cane molasses for lipid, sterol and ergosterol production by Cochliobolus spicifer Nelson,” African Journal of Mycology and Biotechnology, vol. 5, no. 2, pp. 63–72, 1997.

S. S. El-Maraghy, A. A. Zohri, and E. M. S. A. Mostafa, “Accumulation of lipid and sterol by some isolates of Aspergillus niger and A. flavus groups utilizing whey under the influence of trace elements,” in Proceedings of the 3rd Saudi Symposium on Food and Nutrition, pp. 107–116, Faculty of Agriculture, King Saud University, October 1998.

M. S. M. Abd-El-Galil, Side chain degradation and some biological transformations of progesterone by fungi [Ph.D. thesis], Department of Botany, Faculty of Science, Assiut University, Assiut, Egypt, 2000.

S. M. Ragaa Kotby, Production of cyclosporins (immunosuppressive drugs) by fungi [Ph.D. thesis], Department of Botany, Faculty of Science, Assiut University, Assiut, Egypt, 2006.

J.-M. Noh, S.-Y. Kwak, H.-S. Seo, J.-H. Seo, B.-G. Kim, and Y.-S. Lee, “Kojic acid-amino acid conjugates as tyrosinase inhibitors,” Bioorganic and Medicinal Chemistry Letters, vol. 19, no. 19, pp. 5586–5589, 2009.

A. P. D. Rodrigues, A. S. C. Carvalho, A. S. Santos, C. N. Alves, J. L. M. do Nascimento, and E. O. Silva, “Kojic acid, a secondary metabolite from Aspergillus sp., acts as an inducer of macrophage activation,” Cell Biology International, vol. 35, no. 4, pp. 335–343, 2011.

M. S. Madiha, A. G. Baharuddin, M. I. A. Karim et al., “Cultivation characteristics during kojic acid fermentation by local fungus, mutant strain 44-1,” in Proceedings of the 2nd UNESCO National Workshop on Promotion of Microbiology in Malaysia, Universiti Pertanian Malaysia, Selangor, Malaysia, 1993.

S. M. Kharchenko, “The biosynthesis of kojic acid by Aspergillus flavus link strains isolated from feed,” Mikrobiolohichnyi Zhurnal, vol. 61, no. 4, pp. 15–21, 1999.

M. El Khadem, M. S. Tewfik, and Y. A. Hamdi, “The stimulatory effect of kojic acid on the production of aflatoxin by isolates of Aspergillus flavus link,” Zentralblatt für Bakteriologie, Parasitenkunde, Infektionskrankheiten und Hygiene, vol. 131, no. 6, pp. 497–500, 1976.

P. M. Scott, “Mycotoxins in feeds and ingredients and their origin,” Journal of Food Protection, vol. 41, pp. 385–398, 1978.

S. N. Kharchenko, A. I. Yatsyshin, and L. Y. Magdenko, “Koetoxicosis (kojic acid poisoning) in poultry,” Veterinariya, vol. 9, pp. 70–73, 1986.

S. N. Kharchenko, A. I. Iatsyshin, E. M. Tea, N. K. Pototskiǐ, and O. I. Pavlenko, “The species composition of the micromycetes in feed and their role in animal kojic acid toxicosis,” Mikrobiologicheskii Zhurnal, vol. 55, no. 3, pp. 78–84, 1993.

S. E. Megalla, A. Y. Nassar, and M. A. Gohar, “The role of copper(I)-nicotinic acid complex on kojic acid biosynthesis by Aspergillus flavus,” Journal of Basic Microbiology, vol. 27, no. 1, pp. 29–33, 1987.

S. H. El-Sharkawy, “Kojic acid production from cocoa juice by Aspergillus flavus entrapped in calcium alginate,” Bollettino Chimico Farmaceutico, vol. 134, no. 6, pp. 316–319, 1995.

A. B. Ariff, M. Rosfarizan, L. S. Herng, S. Madihah, and M. I. A. Karim, “Kinetics and modelling of kojic acid production by Aspergillus flavus link in batch fermentation and resuspended mycelial system,” World Journal of Microbiology and Biotechnology, vol. 13, no. 2, pp. 195–201, 1997.

M. Manabe, T. Goto, K. Tanaka, and S. Matsuura, “The capabilities of Aspergillus flavus group to produce aflatoxins and kojic acid,” Report of National Food Research Institute, vol. 38, pp. 115–120, 1981.

M. Manabe, K. Tanaka, T. Goto, and S. Matsura, “Producing capability of kojic acid and aflatoxin by mould,” Developments in Food Science, vol. 7, pp. 4–14, 1984.

A. H. Moubasher, M. I. A. Abdel-Kader, and I. A. El-Kady, “Toxigenic fungi isolated from Roquefort cheese,” Mycopathologia, vol. 66, no. 3, pp. 187–190, 1979.

I. A. El-kady, M. B. Mazen, I. S. A. Abd Allah, and A. H. Elyas, “Toxigenicity and toxins produced by fungi isolated from clinically positive pneumonic cases of buffalo Calves,” Assiut Veterinary Medical Journal, vol. 12, pp. 85–88, 1984.

C. I. Wei, I. S. Huang, J. S. Chen, M. R. Marshall, and K. I. Chung, “Production of kojic acid by Aspergillus candidus in three culture media,” Journal of Food Protection, vol. 54, pp. 546–548, 1991.

F. W. Parrish, B. J. Wiley, E. G. Simmons, and L. Long Jr., “Production of aflatoxins and kojic acid by species of Aspergillus and Penicillium,” Applied Microbiology, vol. 14, no. 1, p. 139, 1966.

G. A. Burdock, M. G. Soni, and I. G. Carabin, “Evaluation of health aspects of kojic acid in food,” Regulatory Toxicology and Pharmacology, vol. 33, no. 1, pp. 80–101, 2001.

M. Rosfarizan and A. B. Ariff, “Kinetics of kojic acid fermentation by Aspergillus flavus using different types and concentrations of carbon and nitrogen sources,” Journal of Industrial Microbiology and Biotechnology, vol. 25, no. 1, pp. 20–24, 2000.

M. Y. Kwak and J. S. Rhee, “Cultivation characteristics of immobilized Aspergillus oryzae for kojic acid production,” Biotechnology and Bioengineering, vol. 39, no. 9, pp. 903–906, 1992.

A. Ogawa, Y. Wakisaka, T. Tanaka, T. Sakiyama, and K. Nakanishi, “Production of kojic acid by membrane-surface liquid culture of Aspergillus oryzae NRRL484,” Journal of Fermentation and Bioengineering, vol. 80, no. 1, pp. 41–45, 1995.

Y. Wakisaka, T. Segawa, K. Imamura, T. Sakiyama, and K. Nakanishi, “Development of a cylindrical apparatus for membrane-surface liquid culture and production of kojic acid using Aspergillus oryzae NRRL484,” Journal of Fermentation and Bioengineering, vol. 85, no. 5, pp. 488–494, 1998.

M. Kitada, H. Ueyama, E. Suzuki, and T. Fukumbara, “Studies on kojic acid fermentation. 1: culture conditions in submerged culture,” Journal of Fermentation Technology, vol. 45, pp. 1101–1107, 1967.

M. Rosfarizan, A. Arbakariya, M. Ali Hassan, M. I. Abdul Karim, S. Hiroshi, and S. Suteaki, “Importance of carbon source feeding and pH control strategies for maximum kojic acid production from sago starch by Aspergillus flavus,” Journal of Bioscience and Bioengineering, vol. 94, no. 2, pp. 99–105, 2002.

S. E. Ashari, R. Mohamad, A. Ariff, M. Basri, and A. B. Salleh, “Optimization of enzymatic synthesis of palm-based kojic acid ester using response surface methodology,” Journal of Oleo Science, vol. 58, no. 10, pp. 503–510, 2009.

A. H. El-Refai, Physiological and biochemical studies on the metabolism of fats and sterols in fungi [Ph.D. thesis], Cairo University, Giza, Egypt, 1964.

M. S. Khalifa, Studies on production of single cell protein from vinasse [M.S. thesis], Sugar Technology Research Institute, Assiut University, Assiut, Egypt, 2003.

L.-S. T. Lai, T.-H. Tsai, T. C. Wang, and T.-Y. Cheng, “The influence of culturing environments on lovastatin production by Aspergillus terreus in submerged cultures,” Enzyme and Microbial Technology, vol. 36, no. 5-6, pp. 737–748, 2005.

A. H. El-Refai and I. A. El-kady, “Utilization of some industrial by-products for the micro-biological production of sterol from Sccharomyces fermentati,” Journal of Botany of the United Arab Republic, vol. 12, no. 1, pp. 45–54, 1969.

K. M. Ghanem, N. B. Ghanem, and A. H. El-Refai, “Utilization of beet molasses for sterol production by some moulds,” Microbiologia, vol. 6, no. 1, pp. 37–44, 1990.

S. Kahraman and O. Yeilada, “Industrial and agricultural wastes as substrates for laccase production by white-rot fungi,” Folia Microbiologica, vol. 46, no. 2, pp. 133–136, 2001.

L. A. R. Sallam, A.-M. H. El-Refai, A.-H. A. Hamdy, H. A. El-Minofi, and I. S. Abdel-Salam, “Role of some fermentation parameters on cyclosporin A production by a new isolate of Aspergillus terreus,” Journal of General and Applied Microbiology, vol. 49, no. 6, pp. 321–328, 2003.

S. A. El-Aasar, “Cultural conditions studies on kojic acid production by Aspergillus parasiticus,” International Journal of Agriculture and Biology, vol. 8, pp. 468–473, 2006.

P. Bajpai, P. K. Agrawal, and L. Vishwanathan, “Kojic acid synthesis and propertie,” Journal of Scientific & Industrial Research, vol. 41, pp. 185–194, 1982.

R. Mohamad and A. B. Ariff, “Biotransformation of various carbon sources to kojic acid by cell-bound enzyme system of A. flavus link 44-1,” Biochemical Engineering Journal, vol. 35, no. 2, pp. 203–209, 2007.

T. Futamura, H. Ishihara, T. Tamura et al., “Kojic acid production in an airlift bioreactor using partially hydrolyzed raw corn starch,” Journal of Bioscience and Bioengineering, vol. 92, no. 4, pp. 360–365, 2001.

M. S. LeBlanc and H. A. Akers, “Maltol and ethyl maltol, from larch tree to successful food additives,” Food Technology, vol. 26, pp. 78–87, 1989.

G. J. Nohynek, D. Kirkland, D. Marzin, H. Toutain, C. Leclerc-Ribaud, and H. Jinnai, “An assessment of the genotoxicity and human health risk of topical use of kojic acid [5-hydroxy-2-(hydroxymethyl)-4H-pyran-4-one],” Food and Chemical Toxicology, vol. 42, no. 1, pp. 93–105, 2004.

H. Nakayama, T. Ebihara, N. Satoh, and T. Jinnai, “Depigmentation agents,” in Cosmeceuticals: Drugs vs. Cosmetics, P. Elsner and H. Maibach, Eds., pp. 123–144, Marcel Dekker, New York, NY, USA, 2001.

Anon, Sansei Pharmaceutical Company, Japan. Personal Communications, 1992

J. S. Chen, C. Wei, and M. R. Marshall, “Inhibition mechanism of kojic acid on polyphenol oxidase 1,” Journal of Agricultural and Food Chemistry, vol. 39, no. 11, pp. 1897–1901, 1991.