International Journal of MicrobiologyVolume 2011 (2011), Article ID 641582, 4 pagesdoi:10.1155/2011/641582

Research Article

Deep Conversion of Carbon Monoxide to Hydrogen and Formation of Acetate by the Anaerobic Thermophile Carboxydothermus hydrogenoformans

Anne M. Henstra1,2 and Alfons J. M. Stams²

¹Centre for Biomolecular Sciences, University of Nottingham, University Park, NG7 2RD Nottingham, UK²Laboratory of Microbiology, Wageningen University, Dreijenplein 10, 6703 HB Wageningen, The Netherlands

Received 15 March 2011; Accepted 30 April 2011

Academic Editor: L. Chistoserdova

Copyright © 2011 Anne M. Henstra and Alfons J. M. Stams. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract.

Carboxydothermus hydrogenoformans is a thermophilic strictly anaerobic bacterium that catalyses the water gas shift reaction, the conversion of carbon monoxide with water to molecular hydrogen and carbon dioxide. The thermodynamically favorable growth temperature, compared to existing industrial catalytic processes, makes this organism an interesting alternative for production of cheap hydrogen gas suitable to fuel CO-sensitive fuel cells in a future hydrogen economy, provided sufficiently low levels of CO are reached. Here we study CO conversion and final CO levels in cultures of C. hydrogenoformans grown in batch cultures that were started with a 100% CO gas phase with and without removal of formed CO₂. Final CO levels were 117 ppm without CO₂ removal and below 2 ppm with CO₂ removal. The Gibbs free energy change calculated with measured end concentrations and the detection of acetate suggest that C. hydrogenoformans shifted from a hydrogenogenic to an acetogenic metabolism.

1. Introduction

Carboxydothermus hydrogenoformans is a strictly anaerobic carboxydotrophic hydrogenogenic thermophilic bacterium [1] that conserves energy for growth by performing the water gas shift reaction, the conversion of carbon monoxide with water to hydrogen and carbon dioxide (reaction (1)). The standard Gibbs free energy change of the reaction per mol of CO is relatively small, −20 kJ mol⁻¹. Production of acetate from CO (reaction (2)) or from H₂ and CO₂ (reaction (3)) is not reported for C. hydrogenoformans, despite the presence of the required genes in the genome of C. hydrogenoformans [2]

The water gas shift reaction is applied in industry for production of relative cheap hydrogen gas from synthesis gas. Synthesis gas is a mixture of mainly H₂, CO, and CO₂ which is produced by partial oxidation or autothermal reforming of hydrocarbon-rich sources such as fossil fuels, domestic and agricultural wastes, and other biomass sources [3–5]. Water-gas shift catalysis is applied in successive high and low temperature steps at 400 and 200°C to convert the bulk of CO to final concentrations of not below 1000 ppm. Low-temperature fuel cells are sensitive to CO and require CO levels of below 10 ppm or of a few hundred ppm for novel types that apply improved membranes [6]. Hydrogen gas derived from synthesis gas, while relatively cheap, is therefore not suitable for these types of fuel cells. Highly desired is a water-gas shift process capable of removing CO from synthesis gas to levels below 10 ppm in a single step.

Synthesis gas is also of interest as source for tentative biotechnological processes. Several anaerobic microorganisms are known that can convert the synthesis gas constituents (CO and H₂ + CO₂) into valuable products, for example, methane, ethanol, butanol, and polyhydroxyalkanoates, in what is called synthesis gas fermentation [7, 8]. More microorganisms exist that produce these compounds with only H₂ + CO₂, but these are often sensitive to CO.

Biotechnological application of microorganisms like C. hydrogenoformans to produce a hydrogen gas with minimal CO is thus interesting. They bring the advantage that they operate at lower temperatures than existing water-gas shift catalyst, which is thermodynamically favorable for the removal of CO. Here, we describe the results of a study on CO conversion by and final CO thresholds of C. hydrogenoformans metabolism in batch culture. Removal of CO₂ is studied as it is a means to acquire lower final CO thresholds. The effect on metabolism in relation to minimal free energy change is discussed.

2. Materials and Methods

C. hydrogenoformans (DSM6008) was obtained from the German Culture Collection (DSMZ, Braunschweig) and cultured in 585 mL serum-stoppered bottles in a medium buffered with 200 mL MOPS [9] and a 100% CO gas phase at 65°C and 200 rpm (1″ stroke Innova 44 incubator, New Brunswick Scientific). Bottles contained a glass reaction tube with either 5 mL water as control or 5 mL 10 M NaOH to serve as CO₂ trap. CO, H₂, CO₂, acetate, and growth of C. hydrogenoformans were analysed as described [9]. Gas and liquid samples were taken with intervals of 180 minutes until 15.5 h. Trace levels of CO ( Pa) were analysed on a GC2010 fitted with MTN-1 methanizer (Shimadzu, Japan) and FID by injecting gas samples of 100 μL with a glass gastight syringe that were allowed to equilibrate with atmospheric pressure just before injection into the GC. The Gibbs free energy changes were calculated with observed gas partial pressures and tabulated data for 70°C [10]. Partial pressures of CO₂ and H₂ at 15.5 h were used for calculation of of later samples where only trace CO was measured, unless stated otherwise.

3. Results and Discussion

The metabolic capacity of C. hydrogenoformans cultures to achieve low CO concentrations by CO conversion to H₂ and the effect of CO₂ removal were studied. C. hydrogenoformans was grown in batch cultures with a CO gas phase. Incubations were done with and without a CO₂ trap. The optical density and CO, H₂, and CO₂ concentrations were measured over time (Figure 1). The final pH and acetate concentrations were also measured. With measured concentrations, the Gibbs free energy changes for reaction (1) and (2) were calculated (Table 1).

Table 1: Observed partial pressures and the calculated Gibbs free energy change of CO conversion by C. hydrogenoformans in batch culture.

Culture
(h)
H₂ (Pa)
CO (Pa)
CO₂ (Pa)
Acetate (mM)
(a)
(a)

−CO₂ trap
0.5

0.2 (b)
−53
−52

9.5

−16

55

3.8
+1
−18

+CO₂ trap
0.5

0.2
−57
−52

12.5

−22

55

0.2
−3
−16

(a) and : Gibbs free energy change (kJ/mol CO) for reaction (1) and reaction (2), respectively, at 70°C [10]. (b)Underlined: detection limits that were used in calculation of free energy.

(a)

(b)

(c)

Figure 1: Final CO levels of the hydrogenogenic CO metabolism of C. hydrogenoformans was studied batch cultures, with CO₂ trap and without CO₂ trap (open versus closed symbols, resp.), in triplicate. Optical density of cultures ((a), square symbols), and partial pressures of CO ((b), triangles), H₂ (diamonds), and CO₂ (circles) were monitored over time and plotted on a linear axis. Trace levels of CO (c) were plotted on a logarithmic axis from 15.5 h onward.

The cultures with CO₂ trap showed very similar CO uptake rates and H₂ production rates compared to cultures without trap, however, with a clearly longer lag phase and lower final OD than cultures without trap. Likely, the removal of CO₂ affects growth, as it is an intermediate in the carbon assimilation by C. hydrogenoformans through the acetyl-CoA pathway. Additionally, the CO₂ trap, which is an alkaline solution, could trap the acid gas, H₂S, which serves as source of sulfur and the low redox potential needed for growth of C. hydrogenoformans. Once CO conversion in cultures with CO₂ trap reached comparable rates to cultures without trap, CO₂ started to accumulate until most CO was consumed. Thereafter CO₂ dropped to end point concentrations below the detection limits (<350 kPa). Final CO levels in cultures without CO₂ trap were 117 ppm, while in cultures with CO₂ trap the CO levels had dropped below the detection limit of 2 ppm.

With measured concentrations, using detection limits where concentrations could not be measured, the Gibbs free energy change was calculated for reactions (1) and (2) (Table 1). For reaction (1), the conversion of CO with water to CO₂ and H₂, were +1.4 and −3 kJ/mol CO for cultures without and with CO₂ trap, respectively. These values are closer to thermodynamic equilibrium () than can be expected based on minimal biological energy quantum theory that takes the Gibbs free energy to translocate one proton over the cytoplasmic membrane as minimum, which was assumed −20 kJ mol⁻¹ [11], even when a degree of variability is allowed for the minimal biological energy quantum [12]. Instead of reaction (1), the conversion of CO to H₂, another metabolic reaction that causes the removal of CO in later stages of culture. Acetate was detected in cultures without CO₂ trap, which suggests C. hydrogenoformans shifted from reaction (1) to reaction (2) during cultivation. The for reaction (2) with average concentration of 3.8 mM acetate was −18 kJ mol⁻¹ for cultures without CO₂ trap, which is much closer to theoretical −20 kJ mol⁻¹ of the minimal biological energy quantum. However, in cultures with CO₂ trap, acetate was not detected. The detection limit for acetate was 0.2 mM. It is possible that enough CO or CO₂ was not available to produce more acetate than the detection limit in cultures with CO₂ trap. With 0.2 mM acetate, a of −16 kJ mol⁻¹ CO was calculated which is more in accordance with the minimal biological energy quantum.

4. Conclusion

Batch cultivation of C. hydrogenoformans with CO resulted in final CO concentrations of 117 ppm. With removal of CO₂ during cultivation, even lower CO concentrations of below 2 ppm were reached. The low CO levels in the produced hydrogen-rich gas make the gas suitable for application in CO-sensitive processes. Low-temperature fuel cells require CO to be present below 10 ppm [8]. Improved fuel cell membranes allow several hundred ppm [13, 14]. While the bulk of CO was converted to H₂ by C. hydrogenoformans, it is likely that metabolism shifted to production of acetate from CO in final stages of incubation. Production of acetate by C. hydrogenoformans was not shown before. To apply such a biological catalyst, further research is needed on kinetic aspects, mainly relating to mass transfer at the gas-liquid-microbe interfaces.

Acknowledgments

This research was financed by the Technology Foundation (STW), Applied Science Division of the Netherlands Organisation for Scientific Research (NWO), with the Project no. STW-WBC5280 and additional support from Paques B.V. (Balk, The Netherlands) and Shell Global Solutions (Amsterdam, The Netherlands).

References

V. Svetlitchnyi, C. Peschel, G. Acker, and O. Meyer, “Two membrane-associated NiFeS-carbon monoxide dehydrogenases from the anaerobic carbon-monoxide-utilizing eubacterium Carboxydothermus hydrogenoformans,” Journal of Bacteriology, vol. 183, no. 17, pp. 5134–5144, 2001.

M. Wu, Q. Ren, A. S. Durkin, S. C. Daugherty, L. M. Brinkac, R. J. Dodson, R. Madupu, S. A. Sullivan, J. F. Kolonay, W. C. Nelson, L. J. Tallon, K. M. Jones, L. E. Ulrich, J. M. Gonzalez, I. B. Zhulin, F. T. Robb, and J. A. Eisen, “Life in hot carbon monoxide: the complete genome sequence of Carboxydothermus hydrogenoformans Z-2901,” PLoS Genetics, vol. 1, no. 5, pp. 563–574, 2005.

J. R. Rostrup-Nielsen, “Syngas in perspective,” Catalysis Today, vol. 71, no. 3-4, pp. 243–247, 2002.

N. Piatkowski and A. Steinfeld, “Reaction kinetics of the combined pyrolysis and steam-gasification of carbonaceous waste materials,” Fuel, vol. 89, no. 5, pp. 1133–1140, 2010.

M. M. Yung, W. S. Jablonski, and K. A. Magrini-Bair, “Review of catalytic conditioning of biomass-derived syngas,” Energy and Fuels, vol. 23, no. 4, pp. 1874–1887, 2009.

C. Song, “Fuel processing for low-temperature and high-temperature fuel cells: challenges, and opportunities for sustainable development in the 21st century,” Catalysis Today, vol. 77, no. 1-2, pp. 17–49, 2002.

Y. S. Do, J. Smeenk, K. M. Broer, C. J. Kisting, R. Brown, T. J. Heindel, T. A. Bobik, and A. A. DiSpirito, “Growth of Rhodospirillum rubrum on synthesis gas: conversion of CO to H₂ and poly-β-hydroxyalkanoate,” Biotechnology and Bioengineering, vol. 97, no. 2, pp. 279–286, 2007.

A. M. Henstra, J. Sipma, A. Rinzema, and A. J. M. Stams, “Microbiology of synthesis gas fermentation for biofuel production,” Current Opinion in Biotechnology, vol. 18, no. 3, pp. 200–206, 2007.

A. M. Henstra and A. J. M. Stams, “Novel physiological features of Carboxydothermus hydrogenoformans and Thermoterrabacterium ferrireducens,” Applied and Environmental Microbiology, vol. 70, no. 12, pp. 7236–7240, 2004.

J. P. Amend and E. L. Shock, “Energetics of overall metabolic reactions of thermophilic and hyperthermophilic Archaea and Bacteria,” FEMS Microbiology Reviews, vol. 25, no. 2, pp. 175–243, 2001.

B. Schink, “Energetics of syntrophic cooperation in methanogenic degradation,” Microbiology and Molecular Biology Reviews, vol. 61, no. 2, pp. 262–280, 1997.

T. M. Hoehler, M. J. Alperin, D. B. Albert, and C. S. Martens, “Apparent minimum free energy requirements for methanogenic Archaea and sulfate-reducing bacteria in an anoxic marine sediment,” FEMS Microbiology Ecology, vol. 38, no. 1, pp. 33–41, 2001.

A. T. Haug, R. E. White, J. W. Weidner, and W. Huang, “Development of a novel CO tolerant proton exchange membrane fuel cell anode,” Journal of the Electrochemical Society, vol. 149, no. 7, pp. A862–A867, 2002.

D. C. Papageorgopoulos, M. Keijzer, and F. A. de Bruijn, “The inclusion of Mo, Nb and Ta in Pt and PtRu carbon supported electrocatalysts in the quest for improved CO tolerant PEMFC anodes,” Electrochimica Acta, vol. 48, no. 2, pp. 197–204, 2002.