A series of ceramics samples belonging to the CeO2-Bi2O3 phase system have been prepared via a coprecipitation route. The crystallized phases were obtained by heating the solid precursors at 600∘C for 6 hours, then quenching the samples. X-ray diffraction analyses show that for x<0.20 a solid solution Ce1−xBixO2−x/2 with fluorine structure is formed. For x ranging between 0.25 and 0.7, a tetragonal β′ phase coexisting with the FCC solid solution is observed. For x ranging between 0.8 and 0.9, a new tetragonal β phase appears. The β′ phase is postulated to be a superstructure of the β phase. Finally, close to x=1, the classical monoclinic αBi2O3 structure is observed. Raman spectroscopy confirms the existence of the phase changes as x varies between 0 and 1.
1. Introduction
In the past, several systems based on cerium dioxide CeO2 (ceria) were extensively investigated for their electrochemical, conduction, or catalytic properties [1–15]. Nanostructured powders of pure and doped ceria can be obtained in various ways [16, 17]. In the present work we deal with the bismuth cerium oxide system CeO2-Bi2O3. This system might be of a high interest for catalytic applications and integration in gas sensors. At present, the cerium bismuth oxide phase diagram (CeO2-Bi2O3) is not well known. For low Bi fractions, it was clearly established that a solid solution was formed. The substituted phase Ce1-x4+Bi3+xO2-x/2(V)x/2 with x<0.20 (where oxygen vacancies are noted V) is cubic and its cell parameter increases with x because of size of Bi3+ ionic radius: r(Bi3+)=0.117 nm and r(Ce4+)=0.097 nm [18, 19]. However, above the composition x=0.20, the nature of phases is not well known. In the present work, we describe a new series of observed phases prepared via a coprecipitation route and after heating at 600°C.
2. Experimental
Fourteenth polycrystalline samples were prepared by mixing bismuth and cerium nitrates solutions (Bi(NO3)3, 5H2O + Ce(NO3)3, 6H2O) and adding NH4OH [20, 21] to obtain precipitation of NH4NO3 and bismuth cerium hydroxides. Bismuth compositions ranged from 0% Bi to 100% Bi. The solid obtained by coprecipitation was then heated under air at 600°C for 6 hours. Experiments carried out at intermediate heating times showed that the observed crystallized phases appear as being stable above heating times of 2 hours.
3. Results
The polycrystalline samples were analyzed by X-ray diffraction, using a D5000 Siemens-Bruker diffractometer, equipped with a copper X-ray source (wavelength λ=1.5410-10 m; tension V=45 kV, intensity I=35 mA), and with a monochromator eliminating Kβ radiation. The analyses were carried out using the classical θ-2θ configuration, with 2θ angle steps of 0.02° and counting times of 19 s per step. Raman spectroscopy was used to characterize the observed various phases. A micro-Raman system Horiba. Jobin-Yvon Labram HR 800 equipped with argon laser source (Raman wavelength λ=514.5 nm) was used to observe the various vibrational spectra. All spectra were acquired with a recording time of 30 seconds.
3.1. Structural Studies
X-ray diffraction shows that a strong evolution occurs in the phase system as bismuth atom fraction increases. Figures 1(a), 1(b), 1(c), and 1(d) show the X-ray diffraction patterns for samples noted (1-x)CeO2, x/2Bi2O3 with x varying between 0 and 1. The cell parameters of substituted samples Ce1-xBixO2-x/2(V)x/2 noted as a(x) were refined. From x=0 to x=0.25, the cell parameters linearly vary with x: a(x=0)=0.5409±0.0001 nm; a(x=0.05)=0.5413±0.0001; a(x=0.10)=0.5417±0.0004; a(x=0.15)=0.5419±0.0003; a(x=0.20)=0.5421±0.0002.
XRD patterns (λCuKα1=1.54·10-10m) of pure samples (1-x) CeO2, x/2 Bi2O3 heated at 600°C. (a) XRD patterns for 0<x<0.20; (b): XRD patterns for 0.25<x<0.70 biphasic system; (c) x=0.8 and 0.9; (d) x=1α- Bi2O3.
Above the composition x=0.20, a multiphase system is evidenced and the ceria-based phase presents a constant cell parameter a=0.5421nm: the two new additional phases are identified as being tetragonal and closely related to bismuth oxide structural varieties: their cell parameters were refined. In the composition range from 0.3 to 0.7, a tetragonal β′ phase is observed with refined cell parameters: a=1.5542±0.0003nm; c=0.5645±0.0001nm. It is a superstructure of the tetragonal β phase observed for compositions 0.7<x<0.9, with refined cell parameters: a=0.7742±0.0001nm; c=0.5633±0.0001nm. These substituted phases were never observed, and testing structural models are in progress to better describe these phases.
3.2. Vibrational Studies
raman spectroscopy data are reported on Figures 2(a) and 2(b): in Figure 2(a), the solid solution (0<x<0.25) is characterized by a main vibrational band at 460–465 cm-1 with complementary small bands at 520–590 cm-1 associated with the presence of Bi3+ and oxygen vacancies in the cubic lattice. In Figure 2(b) the Raman spectra of other samples are represented for x compositions ranging between 0.3 and 1. The vibration bands are increasingly more complex as Bi composition increases. The cubic phase of CeO2 is well characterized by the 465 cm-1 Raman band. In the composition range from x=0.05 to 0.20 the bands located at 462–516–595 cm-1 might be associated with the solid solution Ce1-xBixO2-x/2(V)x/2. The additional bands are underlined and should be linked to presence of Bi3+ ions and vacancies (clusters Bi3+-V-Bi3+). In the range x=0.30 to 0.70, the Raman bands 460, 520, 590, 94, 126, 316, 530 (in cm-1) might be related to the biphasic system: cubic solid solution + tetragonal superstructure β’. In the range x=0.80 to 0.90, a new biphasic system associated with the bands 95, 120, 315, 450, 538 (tetragonal phase) and 70, 85, 140, 152, 184, 212, 285, 418, 630 (monoclinic lattice) is observed: these vibration bands could characterize the system “Tetragonal β+ Monoclinic α.” Finally for the Bi2O3 sample, the standard α monoclinic structure is observed.
Raman spectra (λ=514.5nm) of bismuth cerium oxide phases, (1-x) CeO2, x/2. Bi2O3; (a) solid solution for x=0 to 0.25; (b) multiphase system for x=0.30 to 1. Raman shift island are in cm-1, x values from 0 to 1. The bands at 520 and 590 cm-1 are linked to structural defects.
4. Conclusions
New correlations between XRD data and Raman spectroscopy have been established for the system CeO2-Bi2O3. From samples prepared at 600°C, a partial phase diagram is proposed with the probable existence of at least 4 domains. The X-ray diffraction and Raman spectroscopy analyses clearly show that phase changes occur at 600°C, with at least (i) a solid solution domain (cubic phase), (ii) a biphasic domain (tetragonal phase β′ rich in bismuth coexisting with the cubic phase), (iii) a biphasic system with coexistence of two β and β′ tetragonal phases, the β phase being highly rich in bismuth), and finally (iv) a biphasic domain in which monoclinic and tetragonal β phases coexist. The solid solution can be represented from the basic CeO2 face-centered cubic lattice. The tetragonal phase β(x>0.8) can be represented by a cell built on the ceria fcc structure, with lattice vectors (a√2,a√2,a): this structure was previously observed in the literature as a tetragonal variety of pure or non stoichiometric Bi2O3 phase [22, 23]. The Bi rich phase (0.25<x<0.70) having the superstructure noted β′ can be represented by a cell built on lattice vectors (2a√2,2a√2,a). The observed pure Bi2O3 phase is monoclinic. The effective compositions of the β and β′ new cerium bismuth phases are not clearly known and new studies using transmission electron microscopy analyses are in progress.
Acknowledgment
The authors gratefully acknowledge the Provence-Alpes-Côte d’Azur Regional Council, the General Council of Var, and the agglomeration community of Toulon Provence Mediterranean for their helpful financial support in 2007 and 2008.
KašparJ.FornasieroP.GrazianiM.Use of CeO2-based oxides in the three-way catalysis19995022852982-s2.0-0038275393TrovarelliA.Catalytic properties of ceria and CeO2-containing materials199638443952010.1080/016149496080064642-s2.0-0026239476TschöpeA.LiuW.Flytzani-StephanopoulosM.YingJ. Y.Redox activity of nonstoichiometric cerium oxide-based nanocrystalline catalysts1995157142502-s2.0-5814936424110.1006/jcat.1995.1266TschöpeA.YingJ. Y.HadjipanayisG. C.SiegelesR. W.Nanocrystalline cerium oxide catalytic materials1994Dordrecht, The NetherlandsKluwer Academic Publishers781784BakK.HilaireL.Quantitative XPS analysis of the oxidation state of cerium in Pt-CeO2
/Al2O3 catalysts199370-71219119510.1016/0169-4332(93)90425-B2-s2.0-0005883211PalmqvistA. E. C.JohanssonE. M.JäråsS. G.MuhammedM.Total oxidation of methane over doped nanophase cerium oxides1998561697510.1023/A:10190323068942-s2.0-27144534754Martinez-AriasA.Fernandez-GarcíaM.GalvezO.Comparative study on redox properties and catalytic behavior for CO oxidation of CuO/CeO2 and CuO/ZrCeO4 catalysts200019512072162-s2.0-003417723810.1006/jcat.2000.2981AvgouropoulosG.IoannidesT.Selective CO oxidation over CuO-CeO2 catalysts prepared via the urea–nitrate combustion method2003244155167YaoH. C.YaoY. F.Ceria in automotive exhaust catalysts. I. Oxygen storage198486225426510.1016/0021-9517(84)90371-32-s2.0-1542788765MogensenM.SammesN. M.TompsettG. A.Physical, chemical and electrochemical properties of pure and doped ceria2000129163942-s2.0-001610237910.1016/S0167-2738(99)00318-5KirkT. J.WinnickJ.Hydrogen sulfide solid-oxide fuel cell using ceria-based electrolytes1993140123494349610.1149/1.22211172-s2.0-0027709625ŠulcováP.Synthesis of Ce0.95−yPr0.05NdyO2−y/2 pigments20004732852892-s2.0-003450773510.1016/S0143-7208(00)00085-1SadykovV. A.FrolovaY. V.KriventsovV. V.Specificity of the local structure of nanocrystalline doped ceria solid electrolytes2004835199204Materials Research Society Symposium ProceedingsSadykovV. A.KuznetsovaT. G.AlikinaG. M.Ceria-based fluorite-like oxide solid solutions as catalysts of methane selective oxidation into syngas by the lattice oxygen: synthesis, characterization and performance200493–9545532-s2.0-000001608110.1016/j.cattod.2004.05.016LiG.MaoY.LiL.FengS.WangM.YaoX.Solid solubility and transport properties of nanocrystalline(CeO2)1−x(BiO1.5)x by hydrothermal conditions1999115125912662-s2.0-0001303658ÖzerN.Optical properties and electrochromic characterization of sol-gel deposited ceria films2001683-439140010.1016/S0927-0248(00)00371-82-s2.0-0041559008VillainS.LerouxCh.MussoJ.Nanoparticles and thin films of cerium dioxides: relations between elaboration process and microstructure2002125969GilV.MoureC.DuranP.TartajJ.Low-temperature densification and grain growth of Bi2O3-doped-ceria gadolinia ceramics20071785-635936510.1016/j.ssi.2007.02.0022-s2.0-33947243866DikmenS.ShukP.GreenblattM.Hydrothermal synthesis and properties of Ce1−xBixO2−δ solid solutions19981123-42993072-s2.0-0032182657ZhangZ.ZhangY.MuZ.Synthesis and catalytic properties of Ce0.6Zr0.4O2 solid solutions in the oxidation of soluble organic fraction from diesel engines2007763-433534710.1016/j.apcatb.2007.06.0112-s2.0-35448981057IkumaY.TakaoK.KamiyaM.ShimadaE.X-ray study of cerium oxide doped with gadolinium oxide fired at low temperatures2003991–348512-s2.0-001643477510.1016/S0921-5107(02)00546-9HardcastleF. D.WachsI. E.The molecular structure of bismuth oxide by Raman spectroscopy19929723193312-s2.0-0000888913Salazar-PérezA. J.Camacho-LópezM. A.Morales-LuckieR. A.Structural evolution of Bi2O3 prepared by thermal oxidation of bismuth nano-particules200518348