Complementary foods must be adequate to satisfy the nutritional needs of the growing child together with breastfeeding. This study was aimed at evaluating the nutritional composition, microbial safety, and sensory quality of extruded complementary foods developed from blends of staple grains and insect bee larva (Apis mellifera). Teff, maize, soybean, and bee larva samples were milled to flour and blended before extrusion as follows: ComF01 (57% maize, 29% teff, and 14% soybean) and ComF02 (58% maize, 29% teff, and 13% bee larvae) using NutriSurvey software (version, 2007). Nutrient composition, microbial, and sensory analyses of developed flour blends were conducted using standard methods. The proximate composition of moisture, fat, fiber, carbohydrate, and energy was significantly different between the developed and commercial wean-mix foods. ComF02 recorded the highest fat content (14.3 g/100 g), energy (427.18 kcal/100 g), and vitamins A (706 μg/100 g), B3 (8.2 mg/100 g), and B9 (86.7 mg/100 g) while ComF01 had the highest protein content (12.56 g/100 g). Iron (40.94 mg/100 g) and calcium (68.20 mg/100 g) were the minerals with the highest content in ComF02. Both ComF01 and ComF02 met the recommended dietary allowance of nutrients for infants aged 6-12 months. Overall, the present study showed that bee larvae can be used to develop complementary foods that are nutritionally adequate, microbiologically safe, and sensory acceptable meeting the dietary allowance of infants at an acceptable level compared to conventional cereal-based foods.
Deutscher Akademischer Austauschdienst574295631. Introduction
Complementary feeding is the process of providing alternative foods when breast milk alone is no longer sufficient to meet the nutritional requirements of infants, and therefore, other foods and liquids are needed, along with breast milk. Therefore, the infant transitions from exclusive breastfeeding to family foods. This period is typically from 6 to 24 months of age, even though breastfeeding may continue to two years of age and beyond [1]. This is a critical period of growth during which nutrient deficiencies and illnesses contribute globally to higher rates of undernutrition among children under five years of age [2].
While cereals are typically low in protein, cereal supplementation with local legumes that are high in protein improves the protein content of cereal-legume blends [3]. However, these plant diets are inadequate in terms of protein quality hence the need to include animal proteins [4]. Also, due to the increasing cost of animal proteins, food insecurity, population growth, and increasing need for protein-rich food [5], there should find another alternative.
Affordable animal proteins such as edible insects are a strong source of protein with the potential for use in CFs [6, 7]. Insects are protein sources as a nutritious novel food [8]. Insect protein processing is most similar to legume protein processing [9]. The use of edible insects in CF production is not studied abundantly. Only a few studies were conducted using insects as components of CFs such as grasshoppers [7], palm weevil larvae [10, 11], termites [12, 13], crickets [10], and akokono [14] with other local foods. However, a lack of data and information on insect supply and consumption [15] and culture, taboos, customs, and ethnic preferences have highly influenced the consumption of edible insects [16]. Among insects, honey bee larvae (A. mellifera) are a highly promising food resource since honey bees are reared worldwide and eaten as a delicacy in many cultures [17]. Therefore, CFs developed from locally available and acceptable food materials are possible and, when well-formulated, are appropriate for resource-poor settings [18]. Typically, food materials will include staple cereals or starchy tubers [19].
Commercial infant food is very costly in developing countries and may be unavailable to low-income families. Hence, the production of CFs on a small industrial scale may be less costly and affordable to the majority of the population. However, this must have an “easy-to-swallow” consistency and be microbiologically safe when consumed [20]. One of the common industrial techniques for processing CFs is extrusion cooking. This method has various beneficial effects such as reduction of antinutritional factors [21, 22], starch gelatinization [23], increased soluble dietary fiber [24, 25], decreased lipid oxidation [26], and decreased microorganism contamination [27] because of increased temperature and reduced moisture in the foods during extrusion [28]. Studies by [29] reported that teff-based CFs using extrusion cooking influenced nutrient compositions of the developed CFs. Children are at risk of exposure to food-borne pathogens with the introduction of CFs. Therefore, the microbial quality of the food is one of the most important criteria in terms of consumers’ requirements for CFs [28]. Thus, appropriate safe and nutrient-dense CFs [30] should be provided at an appropriate age and development for child growth. This study, therefore, was aimed at evaluating the nutritional composition, microbial safety, and sensory acceptability of complementary foods developed from blends of staple grains and insect bee larva (Apis mellifera) using the extrusion cooking method.
2. Materials and Methods2.1. Sample Collection and Preparation2.1.1. Sample Collection
The bee larva (A. mellifera) was aseptically collected from the University of Gondar apiary farm of modern beehives. The bees were reared in a suitable hygienic environment and fed natural pollen and nectar used for honey production. The fresh larva combs were immediately taken from the beehives and the larvae removed manually from each comb by swing and impact. Red teff (Eragrostis tef (Zucc.)), maize (Zea mays L.), and soybean (Glycine max) were purchased from the Gondar city local market and Gondar Agricultural Research Center, Ethiopia.
2.1.2. Sample Preparation
The bee larvae were oven-dried at 60°C for 24 h, ground to powder, and packaged in an airtight polyethylene bag until analysis [17, 31]. Teff (Eragrostis tef (Zucc. Trotter)) grains were cleaned, washed with tap water until all undesirable components were removed, and then dried by sunlight and grounded to a fine flour using a local stone mill [29, 32]. Maize grain (Zea mays L.) was cleaned, soaked in potable water for 6 h, drained, germinated at room temperature for 48 h, and then sun-dried, dehulled, and milled in local mills to particle sizes ranging from 0.6 mm to 1.0 mm in diameter [33, 34]. The soybeans (Glycine max) were cleaned, boiled (for 30 min), dehulled, and dried at 60°C for about 13 h, milled into flour, and sieved (0.5 mm sieve) [29, 35]. Finally, the flour samples were packed in Ziplock polyethylene bags, labeled, and stored at room temperature until the extrusion process was carried out.
2.2. Formulation of Complementary Foods
Three composite flours with two different ratios were formulated (Figure 1) using NutriSurvey software (version, 2007) according to the guidelines of complementary feeding for children aged 6-12 months [2]. The first CF (ComF01) was composed of maize, teff, and soya bean flours in the ratio of 57 : 29 : 14, respectively. Similarly, the second CF (ComF02) consisted of maize, teff, and bee larva flours in the ratio of 58 : 29 : 13, respectively. Commercial (Enriched Mama’s Choice) prepared infant food was bought from the market for comparison with the formulated flours.
Flow chart of sample processing, formulation, and complementary food products.
2.3. Extrusion Processing
For ease of extrusion and best product quality, the following extrusion parameters were established for a blend formulation of composite flours, using a pilot-scale twin-screw extruder (model Clextral, BC-21 No. 124, Clextral, Firminy, France): moisture content (17%), barrel temperature (150°C), and screw speed [36] with a 29 g/min feed rate. A die plate was used with four circular holes, each with a whole 10 mm diameter. The extrusion feed and water flow rates were adjusted to determine the required moisture content of the samples and were calculated by using [37]
(1)Wa=Sw∗M−Mo100−M,where Wa is the weight of water (g), Sw is the sample flour weight (g), Mo is the original flour moisture content (%), and M is the required moisture content (%).
The extrudates were finally dried and stored at ambient temperatures and then ground using a laboratory-scale mill (high-speed multifunctional grinder model-200) fitted with a 0.5 mm sieve. The flours produced from CFs were packaged in high-density polyethylene bags and stored at dry room temperature until laboratory analyses were carried out.
2.4. Nutrient Analysis2.4.1. Proximate Analysis of Raw Ingredient Flours and Extruded Complementary Foods
The proximate composition of the flours from raw ingredients, the developed complementary foods, and the commercial wean mix were analyzed according to the AOAC International standard methods [38]. Moisture content was determined by the drying method using hot-air oven circulation (method #925.09). Ash content of a known weight sample was determined through incineration (550°C) using a muffle furnace (method #923.03). Crude protein was determined by micro-Kjeldahl (method #979.09) and calculated by multiplying the corresponding total nitrogen content by a factor of 6.25. The crude fat content of the sample was determined by a Soxhlet extractor (method #930.09). Crude fiber content was determined by the following method #962.09. Available carbohydrate was calculated by the difference while energy was calculated using Atwater’s calorie conversion factors of 4 kcal/g for crude protein, 9 kcal/g for crude fat, and 4 kcal/g for available carbohydrate [39].
2.4.2. Micronutrient Analysis
The mineral content of CFs, namely, iron (Fe), zinc (Zn), and calcium (Ca), was determined using a flame atomic absorption spectrometry (Shimadzu AA-6200; Shimadzu, Tokyo, Japan) according to AOAC method 985.35 [38]. The β-carotene content was determined using column chromatography and a Shimadzu UV-Vis spectrophotometer (UV-1601PC, Japan) [40]. The results were converted to vitamin A values using the conversion factor of 6 μg β-carotene: 1 μg RE according to [41]. Vitamin B-complex (B1, B2, B3, B6, and B9) was determined by using High-Performance Liquid Chromatography (HPLC) (Shimadzu, RID-6A) [12].
2.4.3. Antinutrient Analysis
Phytate content was determined according to [42] using the HPLC tannin, and saponin content was determined colorimetrically [43] with a UV-Vis spectrophotometer (Shimadzu model UV–1601 PC, Kyoto, Japan).
2.4.4. Contribution of Complementary Foods to Recommended Dietary Allowance (RDA)
The average contribution of CFs to the RDA of each nutrient was calculated as a percent of the RDA [10].
(2)%RDA=AmountofnutrientanalyzedRDAforagivennutrient×100.
2.4.5. Bioavailability of Minerals
The molar ratios of phytate to zinc, calcium, and iron were calculated as the millimoles of phytate intake per day divided by the millimoles of zinc, calcium, and iron intake per day, respectively [44].
2.5. Microbial Analysis
Microbial analysis was conducted for each CF at day one, three months, and sixth months of storage and commercial wean mix. A serial dilution was done by tenfold and spread-plating techniques. A 1 g sample of each CFs was separately measured aseptically and dispensed separately and mixed with 10 ml diluent saline solution. Then, the food samples were homogenized in diluent for 1 minute using a vortex shaker (Cat AC-H311 made in India). Serial dilutions were made up to 1010 dilution factors [45]. From this homogenized food sample, 1 ml of the sample was transferred to the first cleaned and sterile test tube containing 9 ml diluent by sterile pipette to make a serial 10-2 and 10-4 dilutions of the homogenized sample. Each of these procedures was done in triplicate for each food sample. From each dilution, 1 ml of aliquot was transferred to a Petri dish and spread with a sterile bent glass rod on different types of solid media for the microbial count. To determine the developed foods of total plate count, Escherichia coli (E. coli), Staphylococcus, Salmonella, and Shigella spp, in the food plate count agar, eosin methylene agar, mannitol salt agar, Salmonella, and Shigella agar, respectively, were used and incubated for 24-36 h at 35°C [46, 47]. Yeast and molds were determined by spreading the aliquot on presolidified potato dextrose agar supplemented with 0.1 g chloramphenicol and incubated at 28°C for 5-7 days. Results of the counted colonies were reported as log10 CFU/g [48].
2.6. Sensory Analysis
A sensory evaluation for the acceptability of each CF gruel was done following the instructions of [2]. Gruel was made by adding 50 g of flour to 250 ml of water and cooked. Sensory analysis was performed using 30 semitrained mothers selected that had an acceptable and positive attitude towards eating the products from Gondar town, Ethiopia. Orientation was given for each panelist, how to code sample products for evaluation of appearance, aroma, taste, texture/mouthfeel, and overall acceptability. The mothers were also informed to rinse their mouth with clean water before proceeding to the next food testing. A five-point hedonic scale (5=likeverymuch, 4=likemoderately, 3=neitherlikenordislike, 2=dislikemoderately, and 1=dislikeverymuch) was used [35, 49].
2.7. Statistical Analysis
Results of nutritional composition, microbial, and sensory analysis of CFs were presented as means and standard deviation. One-way ANOVA and Least Significant Difference (LSD) tests were used to determine the differences among means between the CFs using SPSS for Windows Version, 23. The level of significant difference at P<0.05 was considered.
3. Results and Discussion3.1. Nutritional Composition of Ingredients
The proximate composition of foods may be of interest in the food industry for product development, quality control, or regulatory purposes [50]. The proximate composition of individual food ingredients is presented in Table 1. Moisture content of food ingredients ranged from 6.04 to 13.36 g/100 g with high moisture content being recorded for maize (13.36 g/100 g). High protein (50.50 g/100 g) was recorded on soybean followed by bee larvae (45.70 g/100 g), maize (9.79 g/100 g), and teff (9.79 g/100 g). The protein content of soybean reported by [29, 51] was 35.59 and 27 g/100 g, respectively, which was lower than the present study. There were high records of carbohydrate content of teff, followed by maize, soybean, and bee larvae which were 69.55, 72.44, 14.34, and 14.24 g/100 g, respectively.
The results are presented as the SD of the means. Means with different superscripts (alphabets) in the same column are significantly different, P<0.05.
The fat content of soybean was higher than the value reported by [29] and slightly similar to values reported by [51]. Similar findings were on protein and fat content of soaked and germinated maize grain flours reported by [52]. However, flours of teff carbohydrate content were slightly lower than the report of [29, 51]. The variation of all these may be due to genotype, soil fertility, water availability, temperature, and environmental conditions during grain development [53] and the method of processing [54].
Results of honey bee larvae of ash, protein, and fat values of the present study were different from the reports of [31] who reported lower 35.3 g/100 g protein and 14.5 g/100 g fat. Moreover, [55, 56] reported lower ash, protein, and fat content of insect bee larvae compared to our study. The variation may be due to the species of bee insect [57], season and climate [31], and the type of insect feed [58].
3.2. Proximate Composition of CFs and Commercial Wean Mix
Extruded weaning foods were made from a combination of cereals and legumes to produce the correct protein and energy content for growing children [59]. Information about food composition is necessary for the assessment of diet quality and the development and application of food-based dietary guidelines, providing a useful tool for the field of public health nutrition [60]. Table 2 shows the proximate (g/100 g) and mineral (mg/100 g) composition of extruded complementary foods and commercial wean mix and energy content (kcal/100 g).
Proximate (g/100 g), energy content (kcal/100 g), and mineral (mg/100 g) composition of extruded complementary foods and commercial wean mix.
Nutrients
ComF01
ComF02
Commercial wean mix
P value
RV+
Moisture
4.41±0.19b
5.72±0.17a
2.46±0.39c
<0.001
10α
Ash
2.09±0.09a
1.88±0.04b
2.01±0.08ab
0.037
<4α
Protein
12.56±0.17a
11.75±0.15b
10.78±0.29c
<0.01
15+
Fat
12.4±0.1b
14.3±0.1a
2.82±0.36c
<0.001
10-25+
Fiber
4.52±0.04a
3.47±0.08b
2.75±0.17c
<0.001
<5+
Carbohydrate
64.02±0.41b
62.87±0.23c
79.19±0.55a
<0.001
60-75∞
Energy
417.93±3.23b
427.18±2.42a
385.25±1.77c
<0.001
400-425+
Fe
40.17±0.38b
40.94±0.29a
5.79±0.16c
<0.001
9.3∗
Zn
2.84±0.18a
2.92±0.16a
2.32±0.11b
0.006
4.1∗
Ca
31.78±0.11c
44.34±0.49b
68.20±0.12a
<0.001
0.40∗
The results are presented as SD of the means. ComF01: complementary food 01 (white maize+red teff+soybean); ComF02: complementary food 02 (white maize+red teff+insect bee larvae); RV: recommended value; commercial wean mix (Enriched Mama’s Choice); means with different superscripts (alphabets) in the same row are significantly different (P<0.05); ∗sources: [62, 63]; +source [32]; α[64]; ∞estimated from data given for protein and fat in the codex standard.
Moisture, ash, protein, fat, fiber, carbohydrate, and energy (kcal) content of the developed CFs and commercial wean mix met the requirements of the Codex Alimentarius Commission [61]. Statistical analysis showed that there was a statistically significant difference (P=0.037) of ash content between the foods and high records with ComF01 (2.09 g/100 g). There was a significant difference (P≤0.001) between the moisture, fat, fiber, carbohydrate, and energy content of the foods. Moisture, ash, protein, fat, fiber, carbohydrate, and energy (kcal) content of the developed CFs and commercial wean mix met the requirements of the Codex Alimentarius Commission [61].
There was a significant difference (P≤0.001) between the moisture, fat, fiber, carbohydrate, and energy content of the foods. The moisture content of the foods ranged from 2.46 to 5.72 g/100 g. The ComF02 had the highest moisture content (5.72 g/100 g) while the commercial wean mix had the least (2.46 g/100 g). Proteins are important in both quantity and quality, for the rapid growth and development of a child. The protein content of ComF01, ComF02, and commercial wean mix was 12.56, 11.75, and 10.78 g/100 g, respectively. The significantly higher protein content in ComF01 may be due to soybean in the formulation which had higher protein content than bee larvae. However, the values of ComF01 and ComF02 were significantly higher than the commercial wean mix. There was higher fiber (4.52 g/100 g) content on ComF01 followed by ComF02 (3.47 g/100 g) and commercial wean mix (2.82 g/100 g). The highest fat (14.3 g/100 g) and energy (427.18 g/100 g) content was observed in ComF02, while the least fat (2.82 g/100 g) and energy (385.25 g/100 g) were observed in the commercial wean mix. Nutritionally, findings of the energy content of ComF02 were higher than the ComF01 and commercial wean mix might be due to the blends of bee larva in that are high in fat.
Micronutrient deficiency is a common public health problem in developing countries, especially for infants and children in the first two years of life [65]. Iron, zinc, and calcium are important minerals in the complementary feeding of infants and young children. There was a significant difference (P≤0.001) in mineral iron and calcium content between the developed foods and the commercial wean mix (Table 2). High values of iron (40.94 mg/100 g) and calcium (68.20 mg/100 g) were recorded in ComF02 and commercial wean mix, respectively. Mineral iron and calcium composition of both developed CFs were higher than the recommended value [62]. This might be due to the blends of insect bee larvae in complementary foods, which are rich in mineral content [31]. However, the mineral content of zinc did not fulfill the recommended value in all foods. Conversely, the commercial wean-mix zinc (2.32 mg/100 g) was found to be significantly lower (P=0.006) than both food ComF01 and ComF02.
3.3. Vitamin Composition of CFs and Commercial Wean Mix
Establishing precise daily requirements for vitamins is not easy, and there was considerable individual variation; however, achieving the reference nutrient intake (RNI) should be possible with a healthy balanced diet [66]. The vitamin composition of the developed CFs and commercial wean mix is indicated in Table 3. There was a significant difference (P≤0.001) of vitamin composition between the developed CFs and commercial wean mix. Results of vitamin A showed that ComF02 and commercial wean mix fulfilled the recommended value [63]. Vitamin A content of commercial wean mix (2.08 mg/100 g) was higher than that of ComF01 (0.16 mg/100 g) and ComF02 (0.71 mg/100 g), respectively. Vitamin A content of ComF01 (0.16 mg/100 g) did not meet the recommended value for infants and children. Vitamins thiamine (0.81 mg/100 g) and riboflavin (0.70 mg/100 g) value of ComF01 had highest values, however, low records of pyridoxine (0.29 mg/100 g) and folate (51 μg/100 g). Also, niacin (8.20 mg/100 g) and folate (86.7 μg/100 g) in ComF02 were high but could not meet the recommended value of riboflavin.
Vitamin composition of complementary foods and commercial wean mix per 100 g.
Vitamins
ComF01
ComF02
Commercial wean mix
P value
RVα
Vitamin A (μg)
167.3±5.84c
706.8±16.28b
2082.02±85.08a
<0.001
400
B1 (thiamine) (mg)
0.81±0.09a
0.48±0.06b
0.24±0.36c
<0.001
0.36
B2 (riboflavin) (mg)
0.70±0.07a
0.26±0.03c
0.44±0.20b
<0.001
0.36
B3 (niacin) (mg)
5.23±0.41bc
8.20±0.32a
6.33±1.43c
<0.001
6.0
B6 (pyridoxine) (mg)
0.29±0.019c
0.45±0.01ab
0.53±0.47a
<0.001
0.44
B9 (folate) (μg)
51.0±4.9c
86.70±1.80a
77.76±16.31ab
<0.001
83
The results are presented as SD of the means. ComF01: complementary food 01 (white maize+red teff+soybean); ComF02: complementary food 02 (white maize+red teff+insect bee larvae); RV: recommended value; commercial wean mix (Mama’s Choice); means with different superscripts (alphabets) in the same row are significantly different P<0.05; αsources [63].
3.4. Contribution to Recommended Dietary Allowance (RDA)
Table 4 summarizes the percentage contribution of macro- and micronutrients provided by complementary foods and commercial wean mix which met RDA for 6-12 months. The contribution of ComF01, ComF02, and commercial wean mix to the RDA of protein was the highest which was 114.18, 106.82, and 98%, respectively; however, with the exception of the energy contribution from ComFs02, the contribution of the two CFs to the RDA of energy for infants was less than 50%. All foods had the potential to contribute to the RDA of iron (52.64-365.18%) and zinc (73.33-97.33%); however, the contribution of calcium (12.22-26.23%) intake was very low. The vitamins’ potential contribution of CFs to the RDA were highest except ComF01 for vitamin A (33.34%).
Percentage contribution of macro- and micronutrients provided by complementary foods and commercial wean mix meeting RDA for 6-12 months.
Antinutrients in complementary foods for children could have a negative impact on nutritional status [68]. Therefore, using extrusion significantly reduced the antinutritional factors of the formulated diets [22]. Antinutrient composition of developed CFs in mg/100 g is shown in Table 5.
Antinutrient composition of developed complementary foods (mg/100 g).
CFS
Antinutrients
Tannins
Phytates
Saponins
ComF01
208.93±0.04a
68.18±4.15a
nd
ComF02
119.37±0.31b
13.13±0.63b
nd
Commercial wean mix
63.69±0.34c
10.46±0.5b
nd
P value
<0.001
<0.001
—
The results are presented as SD of the means. ComF01: complementary foods (white maize+red teff+soybean); ComF02: complementary foods (white maize+red teff+insect bee larvae); nd: not detected.
Antinutritional (mg/100 g) content showed high records of tannins (208.93) and phytates (68.18) in ComF01 than in ComF02 and commercial wean mix which showed tannins of 119.37 and 63.60 and phytates of 13.13 and 10.46, respectively. However, saponins were not detected in both CFs and commercial wean mix. Cereal-based complementary foods are high in phytates which limit the bioavailability of nutrients, including iron, calcium, zinc, and, in some cases, proteins, which are crucial to the development of infants [69]. Tannin-protein complexes can contribute to digestive enzyme inactivation and decrease the digestibility of proteins by protein substrate association with ionizable iron [70]. The existence of tannins in food could reduce the quality of foods, suppress growth, reduce iron absorption, harm the gastrointestinal tract’s mucosal lining, altercation excretion, and increase protein and critical amino acid excretion [22].
3.6. Bioavailability of Minerals
The calculated results of both CF concentration of phytate and its molar ratio of minerals calcium, iron, and zinc were in line with the recommended limits (Table 6).
Minerals : phytate molar ratio in developed complementary foods and commercial wean mix.
The recommended limits of phytate to calcium, iron, and zinc were phytatetocalcium<0.24 for calcium [74], phytatetoiron<1 for iron [71], and phytatetozinc<15 for zinc [72]. (0.14, 0.03, and 0.02), calcium (2.40, 0.45, and 0.45), and zinc (0.13, 0.02, and 0.01), respectively, showed good iron, zinc, and calcium bioavailability in both developed complementary foods and commercial wean mix. This might be due to the low amounts of phytate in the CFs. Also, the addition of legumes (ComF01) can slightly improve the iron content of those diets; however, the bioavailability of this nonheme iron source was lower than hemi iron [41]. According to the report of [75], lowering the phytic acid should enhance the bioavailability of iron and zinc in the extrudates as phytic acid has been implicated in making these minerals unavailable. Extrusion cooking results in the degradation of cereals and legumes’ antinutrients by about 30% [76]. The inhibitory effect of phytate on bioavailability increases with the increment of phytate intake [77]. In the gastrointestinal tract, phytic acid binds trace elements and macro elements such as copper, calcium, magnesium, and iron to make dietary minerals inaccessible for consumption and used by the body [78].
3.7. Microbiological Loads of CFs
The microbial load of any food material is, however, a useful index of quality of the extrudate as well as revealing the potential safety status of the extruded food products from a human consumption point of view and storage of the products [45]. Table 7 summarizes the microbiological counts (log10 CFU/g) of the developed CFs at day one and after storage of three months and six months and commercial wean mix.
Microbiological counts (log10 CFU/g) of the developed complementary foods after three and six months of storage and commercial wean mix.
Microorganisms
At 3 months
At 6 months
Commercial wean mix
Limit∗
ComF01
ComF02
ComF01
ComF02
E. coli
nd
nd
nd
nd
nd
<1
S. aureus
nd
nd
nd
nd
nd
<1
Salmonella
nd
nd
nd
nd
nd
0/25 g
Shigella
nd
nd
nd
nd
nd
0/25 g
Total plate count
3.36
3.04
3.46
3.17
Nil
<5
Yeast
2.00
2.00
2.30
2.18
Nil
<3
Molds
2.17
2.30
2.60
2.40
Nil
<3
Results are presented as means. CFU: colony forming units; nd: not detected; ∗[64, 79].
The microbial results of both CFs were below the acceptable level, i.e., acceptable limit (<5 log10 CFU/g) [64] and not detected on commercial wean mix. High levels of moisture (above 10%) exacerbate spoilage by encouraging microbial activity and chemical reactions that reduce the shelf life of the food [80]. Therefore, microbial counts of E. coli, Staphylococcus, Salmonella, and Shigella spp, total plate count, yeast, and mold of both CFs were within safe levels. This may be due to the quality control measures used during manufacturing and techniques [81, 82] as well as because of low moisture content [83].
On day one, microbial counts of both CFs were not detected. Similarly, at six months of storage, there were no E. coli, Staphylococcus, Salmonella, and Shigella spp detected. The findings of bacterial Shigella, Salmonella, and Staphylococcus spp of the present study were in line with the study of [84], which were not detected from the developed weaning food samples. This was likely since these were not persistent in the environment or were more likely destroyed during cooking [85, 86].
There was a slight increment of microbial load at three and six months of storage. The mean total plate count of ComF01 (3.36 log10 CFU/g) and ComF02 (3.04 log10 CFU/g) were recorded at three months and ComF01 (3.46 log10 CFU/g) and ComF01 (3.17 log10 CFU/g) at six months of storage. The detection of total plate counts in the CFs at an acceptable level could be due to cross-contamination through the migration of substances from the packaging into food [87] or storage time increased [45] or contamination of packaging material [88–90].
Yeast counts of ComF01 at three (2.0 log10 CFU/g) and six (2.30 log10 CFU/g) months of storage were as mean mold counts at three (2.17 log10 CFU/g) and six (2.60 log10 CFU/g) months of storage were recorded. Yeast counts of ComF02 at three (2.00 log10 CFU/g) and six months (2.18 log10 CFU/g) and mold at three (2.30 log10 CFU/g) and six months (2.40 log10 CFU/g) were recorded. The presence of molds and yeast development in the developed CFs after three and six months of storage might be due to packaging or storage conditions. Most yeasts and molds were obligatorily aerobic, and their temperature range (10-35°C) was also broad [91]. Comparing yeast and molds, higher mold counts (CFU/g) of the developed CFs were recorded than yeast in both CFS but not detected on commercial wean mix. This may be due to molds’ moisture requirements being relatively low, although yeasts generally require higher water activity [92]. Therefore, suppression of microbial growth appears to be favored under high temperature and low moisture environments [93].
3.8. Sensory Analysis
The sensory analysis relies on consumers to provide the data on which decisions were based [94]. Sensory attributes and overall acceptance of commercial wean mix (Table 8) were higher than those of ComF01 and ComF02. The small number of participants used in the sensory test increased the chance of getting accurate and reliable results [95]. There was a statistically significant difference (P=0.003) in appearance and aroma between the developed CFs and commercial wean mix. The appearance was an important attribute in food choice and acceptance [96]. The outcome of the sensory evaluation indicated that ComF01 and ComF02 samples were similar in appearance while the commercial wean mix differed significantly. However, ComF01 had a lower score of overall acceptance than ComF02. This may be due to the higher presence of tannins in ComF01. According to the report of [75], tannins also decrease palatability. There was a highly significant difference (P≤0.001) between the foods with regard to taste, texture, and overall acceptability. The aroma, taste, and overall acceptability of ComF02 were liked more by the panelists as compared to those of ComF01 but were of lower acceptability than those of the commercial wean mix. The best score rating of the commercial wean mix would be as a result of flavoring additions in the product [97].
Sensory analysis of the developed complementary foods compared to commercial wean mix.
Characteristic
ComF01
ComF02
Commercial wean mix
P value
Appearance
3.77 ± 0.82c
4.07 ± 0.69bc
4.41 ± 0.74a
0.003
Aroma
3.73 ± 0.91c
4.23 ± 0.63ab
4.40 ± 0.80a
0.003
Taste
3.57 ± 0.73c
4.43 ± 0.63ab
4.50 ± 0.68a
<0.001
Texture/mouth feel
3.77 ± 0.71c
3.97 ± 0.61bc
4.47 ± 0.51a
<0.001
Overall acceptability
3.63 ± 0.61c
4.20 ± 0.55b
4.63 ± 0.49a
<0.001
The results are presented as SD of the means. ComF01: complementary foods 01 (white maize+red teff+soybean); ComF02: complementary foods 02 (white maize+red teff+insect bee larvae); commercial wean mix (Mama’s Choice); means with different superscripts (alphabets) in the same row are significantly different (P<0.05).
Infants and toddlers present a challenge to sensory and consumer researchers because of their inability to communicate verbally, limited cognitive abilities, and very low attention span [98]. Besides, most found young children to have lower sensitivity than adults [99]. Sensory testing with infants and young children, therefore, has often employed indirect approaches. Therefore, the sensory evaluation of the present study was conducted by mothers or caretakers. For preference evaluation, parents’ liking is important in deciding if a given CF would be suitable for their infants [100, 101]. All sensory evaluations of the developed CFs and commercial wean mix were above the minimum threshold i.e., the hedonic scale which was equal to three, neither likes nor dislikes [10].
4. Conclusions
The present study revealed that the development of CFs using extrusion cooking makes the products desirable in nutritional quality, microbial safety, and sensory acceptability. The nutritional composition of the developed foods meets the Codex Alimentarius Standard of the recommended dietary allowance for infants. The potential of using bee larvae as a novel ingredient in the development of CFs has been an alternative protein gained from plant-based protein sources. Using bee larvae with staple grains as a component of CFs is appropriate for macro- and micronutrient improvement of CF development for infants and young children. The extruded complementary foods containing bee larvae can be microbially safe and acceptable similar to cereal-based complementary foods and have the potential to contribute to the recommended dietary allowance. However, further study should be done on the effects of the developed CF foods on biochemical, hematological, and histopathological changes using laboratory animals.
Data Availability
The data used and/or analyzed in the study are available from the corresponding author on reasonable request.
Conflicts of Interest
The authors declare that there is no conflict of interest regarding the publication of this paper.
Acknowledgments
The authors would like to give special thanks to the German Academic Exchange Service (DAAD) for the sponsorship of this research work. We are also grateful to Jomo Kenyatta University of Agriculture and Technology, Kenya; Holeta Agricultural Center; Bahir Dar University; and University of Gondar, Ethiopia, for this research laboratory work. This research was funded by DAAD/RUFORUM, In-Country/In-Region Scholarship Programme–Regional Universities Forum for Capacity Building in Agriculture 2018, Germany, grant number (57429563).
WHO2019WFP2018https://docs.wfp.org/api/documents/WFP-0000102245/download/AbdulkadirM.DanjumaJ. B.Microbial profile and nutritional quality during the fermentation of cereal based weaning food fortified with soya bean and tiger nut using starter culture201524103115HenchionM.HayesM.MullenA. M.FenelonM.TiwariB.Future protein supply and demand: strategies and factors influencing a sustainable equilibrium2017675310.3390/foods607005328726744TiencheuB.WomeniH.Entomophagy: insects as food2017IntechOpen233253AdámkováA.MlčekJ.KouřimskáL.BorkovcováM.BušinaT.AdámekM.BednářováM.KrajsaJ.Nutritional potential of selected insect species reared on the island of Sumatra201714552110.3390/ijerph140505212-s2.0-8501917352928498340MmariM.KinyuruJ. N.LaswaiH. S.OkothJ.Application of edible insects in enriching complementary foods made from common plant sourcesPaper presented at the Fifth African Higher Education Week and RUFORUM Biennial Conference 2016, "Linking Agricultural Universities with Civil Society, the Private Sector, Governments and Other Stakeholders in Support of Agricultural Development in Africa"2016Cape Town, South Africahttp://repository.ruforum.org/KinyuruJ. N.KonyoleS. O.Onyango-OmoloS. A.KenjiG. M.OnyangoC. A.OwinoV. O.OwuorB. O.EstambaleB. B.RoosN.Nutrients, functional properties, storage stability and costing of complementary foods enriched with either termites and fish or commercial micronutrients20151214915810.3920/jiff2014.00112-s2.0-85006079006GravelA.DoyenA.The use of edible insect proteins in food: challenges and issues related to their functional properties20205910227210.1016/j.ifset.2019.102272AgbemafleI.HadziD.AmaglohF. K.ZotorF. B.ReddyM. B. J. F.Nutritional, microbial, and sensory evaluation of complementary foods made from blends of orange-fleshed sweet potato and edible insects202099122510.3390/foods9091225AyensuJ.LarbieC.AnnanR. A.LutterodtH.EduseiA.LohS. P.AsiamahE. A.Palm weevil larvae (Rhynchophorus phoenicis Fabricius) and orange-fleshed sweet potato-enriched biscuits improved nutritional status in female Wistar albino rats202020201810.1155/2020/806136532322416AdepojuO. T.AjayiK.Nutrient composition and adequacy of two locally formulated winged termite (Macrotermes bellicosus) enriched complementary foods201654798910.5539/jfr.v5n4p79KinyuruJ. N.MogendiJ. B.RiwaC. A.Ndung'uN. W.Edible insects—a novel source of essential nutrients for human diet: learning from traditional knowledge201552141910.2527/af.2015-00142-s2.0-84989908861ParkerM. E.ZobristS.LutterodtH. E.AsieduC. R.DonahueC.EdickC.MansenK.PeltoG.MilaniP.SoorS.LaarA.Evaluating the nutritional content of an insect-fortified food for the child complementary diet in Ghana20206111110.1186/s40795-020-0331-6RoosN.Insects and human nutrition2018Springer8391KinyuruJ. N.NyangenaD.KamauE.NdirituA.MuniuJ.KipkoechC.WeruJ.Ndung’uN.MmariM.The role of edible insects in diets and nutrition in East Africa2018Springer93108JensenA. B.EvansJ.Jonas-LeviA.BenjaminO.MartinezI.DahleB.RoosN.LecocqA.FoleyK.Standard methods for Apis mellifera brood as human food201958212810.1080/00218839.2016.12266062-s2.0-84992092069KonyoleS. O.KinyuruJ. N.OwuorB. O.KenjiG. M.OnyangoC. A.EstambaleB. B.FriisH.RoosN.OwinoV. O.Acceptability of amaranth grain-based nutritious complementary foods with dagaa fish (Rastrineobola argentea) and edible termites (Macrotermes subhylanus) compared to corn soy blend plus among young children/mothers dyads in Western Kenya20121311112010.5539/jfr.v1n3p111NoutM. J. R.Processed weaning foods for tropical climates199343421322110.3109/096374893090275452-s2.0-0000003890UNICEFImproving young children’s diets during the complementary feeding period2020New YorkUNICEF76NikmaramN.LeongS. Y.KoubaaM.ZhuZ.BarbaF. J.GreinerR.OeyI.RoohinejadS.Effect of extrusion on the anti-nutritional factors of food products: an overview201779627310.1016/j.foodcont.2017.03.0272-s2.0-85016136335OmosebiM. O.OsundahunsiO. F.FagbemiT. N.Effect of extrusion on protein quality, antinutritional factors, and digestibility of complementary diet from quality protein maize and soybean protein concentrate2018424, article e1250810.1111/jfbc.125082-s2.0-85041215953WangP.FuY.WangL.SalehA. S.CaoH.XiaoZ.Effect of enrichment with stabilized rice bran and extrusion process on gelatinization and retrogradation properties of rice starch2017697-8160020110.1002/star.2016002012-s2.0-85013392847RashidS.RakhaA.AnjumF. M.AhmedW.SohailM.Effects of extrusion cooking on the dietary fibre content and water solubility index of wheat bran extrudates20155071533153710.1111/ijfs.127982-s2.0-84930925943ZhongL.FangZ.WahlqvistM. L.HodgsonJ. M.JohnsonS. K.Extrusion cooking increases soluble dietary fibre of lupin seed coat20199954755410.1016/j.lwt.2018.10.0182-s2.0-85054792293ArtzW. E.RaoS. K.Lipid oxidation in extruded products1993543American Chemical Society296314Almendares CalderónL.García MenaV. A.Román MirandaJ. M.Development of an extruded food product similar to fried potatoes, based on by-products of potatoes and rice. Physicochemical and microbiological evaluation20214135936410.1590/fst.03820BaskarG.AiswaryaR.Role of extrusion technology in food processing and its effect on nutritional values20161114TenagashawM. W.KenjiG. M.MelakuE. T.Huyskens-KeilS.KinyuruJ. N.Teff-based complementary foods fortified with soybean and orange-fleshed sweet potato20166111212210.5539/jfr.v6n1p112WHO2009World Health OrganizationGhoshS.JungC.Meyer-RochowV. B.Nutritional value and chemical composition of larvae, pupae, and adults of worker honey bee, Apis mellifera ligustica as a sustainable food source201619248749510.1016/j.aspen.2016.03.0082-s2.0-84967313048CodexA.Guidelines on formulated complementary foods for older infants and young children. Amended document 19912017AbebeY.StoeckerB. J.HindsM. J.GatesG. E.Nutritive value and sensory acceptability of corn-and kocho-based foods supplemented with legumes for infant feeding in southern Ethiopia200661119TonaZ.TafeseB.TeferaB.Blending germinated maize, pumpkin pulp and its seed improves zinc and vitamin A without compromising nutritive value and sensory attributes of local complementary food porridge201554103107ForsidoS. F.DugumaH. T.LemaT. B.SturmB.HenselO.Nutritional and sensory quality of composite extruded complementary food20197288288910.1002/fsn3.9402-s2.0-8506208663530847167MaruvadaP.LampeJ. W.WishartD. S.BarupalD.ChesterD. N.DoddD.Djoumbou-FeunangY.DorresteinP. C.DragstedL. O.DraperJ.DuffyL. C.Perspective: dietary biomarkers of intake and exposure-exploration with omics approaches201911220021510.1111/jfbc.130102-s2.0-85070528816GolobP.FarrellG.OrchardJ. E.2002Wiley Online Library10.1002/9780470751015AOAC200518thGaithersburg, MdAOAC internationalFAO2003RomeFaoBiswasA.SahooJ.ChatliM.A simple UV-Vis spectrophotometric method for determination of β-carotene content in raw carrot, sweet potato and supplemented chicken meat nuggets20114481809181310.1016/j.lwt.2011.03.0172-s2.0-79956301573WHO/FAO20042Washington, DCNational Academy PressCamireA.ClydesdaleF.Analysis of phytic acid in foods by HPLC198247257557810.1111/j.1365-2621.1982.tb10126.x2-s2.0-84986531914SingletonV. L.RossiJ. A.Colorimetry of total phenolics with phosphomolybdic-phosphotungstic acid reagents1965163144158Castro-AlbaV.LazarteC. E.BergenståhlB.GranfeldtY.Phytate, iron, zinc, and calcium content of common Bolivian foods and their estimated mineral bioavailability2019792854286510.1002/fsn3.11272-s2.0-8507376561431572579OluwoleO.AwonorinS.HenshawF.ElemoG.EbuehiO.Assessment of microbial changes and nutritional qualities of extruded white yam (Dioscorea rotundata) and bambara groundnut (Vigna subterranean) blends20134110010710.4236/fns.2013.41014AnigoK.AmehD.IbrahimS.DanbauchiS.Nutrient composition of complementary food gruels formulated from malted cereals, soybeans and groundnut for use in North-Western Nigeria201043657210.5897/AJFS.9000200GetachewG.Microbiological quality of traditional and commercial weaning foods in Jimma town Southwestern Ethiopia201763SpencerJ. F.de SpencerA. L. R.Food microbiology protocols200114MeilgaardM. C.CarrB. T.CivilleG. V.2006CRC press10.1201/b16452NielsenS. S.Proximate assays in food analysis200671213110.1002/9780470027318.a1024MenureH.Effect of grain teff, sorghum and soybean blending ratio and processing condition on weaning food quality20178310.4172/2157-7110.1000659GebrezgiD.Proximate composition of complementary food prepared from maize (Zea mays), soybean (Glycine max) and Moringa leaves in Tigray, Ethiopia201951162777910.1080/23311932.2019.1627779RooneyL.Sorghum and millets1996Springer153177Jean MayerB. S. S.The effects of food processing on nutritional values197533412312610.1111/j.1753-4887.1975.tb07435.x2-s2.0-00167319711128857HockingB.MatsumuraF.Bee brood as food196041511312010.1080/0005772X.1960.11096777KrellR.1996Food & Agriculture OrgChapmanC. A.ChapmanL. J.RodeK. D.HauckE. M.McDowellL. R.Variation in the nutritional value of primate foods: among trees, time periods, and areas200324231733310.1023/A:10230492001502-s2.0-0037395202KouřimskáL.AdámkováA.Nutritional and sensory quality of edible insects20164222610.1016/j.nfs.2016.07.0012-s2.0-84979035649FellowsP. J.FellowsP. J.2017fourthWoodhead publishingElmadfaI.MeyerA. L.Importance of food composition data to nutrition and public health201064S3S4S710.1038/ejcn.2010.2022-s2.0-78149241658CodexA. C.2010DeweyK. G.BrownK.Update on technical issues concerning complementary feeding of young children in developing countries and implications for intervention programs200324152810.1177/1564826503024001022-s2.0-003735398712664525FAO/WHO200257GenevaWorld Health OrganizationWFP2013WFP Specification for Fortified Blended Foodhttps://documents.wfp.org/stellent/groups/public/documents/manual_guide_proced/wfp251160EichlerK.WieserS.RüthemannI.BrüggerU.Effects of micronutrient fortified milk and cereal food for infants and children: a systematic review201212150610.1186/1471-2458-12-5062-s2.0-84863471610LeafA. A.Vitamins for babies and young children200692216016410.1136/adc.2006.1090662-s2.0-33847082129National Academies of Sciences, Engineering, and Medicine; Health and Medicine Division; Food and Nutrition Board; Committee to Review the Dietary Reference Intakes for Sodium and PotassiumOriaM.HarrisonM.StallingsV. A.2019Washington (DC)National Academies Press (US)RoosN.SørensenJ. C.SørensenH.RasmussenS. K.BriendA.YangZ.HuffmanS. L.Screening for anti-nutritional compounds in complementary foods and food aid products for infants and young children20139477110.1111/j.1740-8709.2012.00449.x2-s2.0-84869743111AmaglohF. K.HardacreA.MutukumiraA. N.WeberJ. L.BroughL.CoadJ.Sweet potato-based complementary food for infants in low-income countries201233131010.1177/1564826512033001012-s2.0-8485903156322624294OgunkoyaM.AbuludeF.OniA.Determination of anatomical, proximate, minerals, oxalate, tannin and phytate compositions of Cuban Boa (Epicrates anquifer)20065111611166HallbergL.BruneM.RossanderL.Iron absorption in man: ascorbic acid and dose-dependent inhibition by phytate198949114014410.1093/ajcn/49.1.1402-s2.0-00245203262911999SandbergA.-S.AnderssonH.CarlssonN.-G.SandströmB.Degradation products of bran phytate formed during digestion in the human small intestine: effect of extrusion cooking on digestibility1987117122061206510.1093/jn/117.12.20612-s2.0-00236224282826727BindraG. S.GibsonR. S.ThompsonL. U. J. N. R.[Phytate][calcium]/[zinc] ratios in Asian immigrant lacto-ovo vegetarian diets and their relationship to zinc nutriture198665475483MorrisE. R.EllisR.Usefulness of the dietary phytic acid/zinc molar ratio as an index of zinc bioavailability to rats and humans1989191-210711710.1007/BF029254522-s2.0-0024313039AnuonyeJ. C.JigamA. A.NdacekoG. M.Effects of extrusion-cooking on the nutrient and anti-nutrient composition of pigeon pea and unripe plantain blends201225158162SatheS. K.VenkatachalamM.2002Washington, DCCRC PressAl HasanS. M.HassanM.SahaS.IslamM.BillahM.IslamS. J. B. N.Dietary phytate intake inhibits the bioavailability of iron and calcium in the diets of pregnant women in rural Bangladesh: a cross-sectional study2016212410.1186/s40795-016-0064-8RamakrishnaV.RaniP. J.RaoP. R.Anti-nutritional factors during germination in Indian bean (Dolichos lablab L.) seeds200611611ICMSF1978University of Toronto Presshttp://worldcat.org/z-wcorg/AmegovuA. K.OgwokP.OcholaS.YigaP.MusalimaJ. H.MutenyoE.Formulation of sorghum-peanut blend using linear programming for treatment of moderate acute malnutrition in Uganda2013126777ObiC.NwozorN.Bacteriological analyses of weaning foods consumed in Umuariaga community, Ikwuano L.G.A. Abia state20127420821110.3923/rjasci.2012.208.2112-s2.0-84864002414SuleimanR. A.RosentraterK. A.BernC. J.Effects of deterioration parameters on storage of maize2013110.13031/aim.20131593351SrivalliR.KumariB. A.MaheswariK. U.SuneethaW. J.PrabhakarB. N.Shelf life studies of tomato powder incorporated cold extrudates2017641569157510.20546/ijcmas.2017.604.193CetinkayaF.CibikR.SoyutemizG. E.OzakinC.KayaliR.LeventB.Shigella and Salmonella contamination in various foodstuffs in Turkey200819111059106310.1016/j.foodcont.2007.11.0042-s2.0-44649182397MuletaD.AshenafiM.Salmonella, Shigella and growth potential of other food-borne pathogens in Ethiopian street vended foods2001781157658010.4314/eamj.v78i11.89462-s2.0-003552739812219962VermaT.2017https://digitalcommons.unl.edu/foodscidiss/83/GungorE.GokogluN.Determination of microbial contamination sources at a frankfurter sausage processing line2010341536010.3906/vet-0805-282-s2.0-77953784675LauO. W.WongS.Contamination in food from packaging material20008821-225527010.1016/S0021-9673(00)00356-32-s2.0-003467455010895950TshipambaM.LubanzaN.AdetunjiM.MwanzaM.Evaluation of the effect of hygiene practices and attitudes on the microbial quality of street vended meats sold in Johannesburg, South-Africa2018313724763059Uzma AltafF. I.HussainS. Z.IshratS. A.AyazQ.Shelf life studies of the optimized extruded product developed by severe extrusion processing201975667670ValerieT. M.MislivecP. B.KochH. A.BandlerR.United States Food Drug Administration2001Gaithersburg, Md.AOAC InternationalStannardC. J.PetittS. B.SkinnerF. A.1989Oxford; BostonBrookline Village, Mass.: Blackwell Scientific Publications ; Publishers' Business Services [distributor]SpencerJ. F.SpencerA. L.de200114Springer Science & Business MediaStoneH.Example food: what are its sensory properties and why is that important?20182110.1038/s41538-018-0019-3SvenssonL.2012Uppsala(Masters independent project/degree project in food science – Master’s thesis), Swedish University of Agricultural Scienceshttp://stud.epsilon.slu.se/MuhimbulaH. S.Issa-ZachariaA.KinaboJ.Formulation and sensory evaluation of complementary foods from local, cheap and readily available cereals and legumes in Iringa, Tanzania201151263110.5897/AJFS.9000142Ikpeme-EmmanuelC. A.OkoiJ.OsuchukwuN. C.Functional, anti-nutritional and sensory acceptability of taro and soybean based weaning food2009311372377LavinJ. G.LawlessH. T.Effects of color and odor on judgments of sweetness among children and adults19989428328910.1016/S0950-3293(98)00009-32-s2.0-0031877186GuinardJ.-X.Sensory and consumer testing with children200011827328310.1016/S0924-2244(01)00015-22-s2.0-0034447682Haro-VicenteJ. F.Bernal-CavaM. J.Lopez-FernandezA.Ros-BerruezoG.BodenstabS.Sanchez-SilesL. M. J. N.Sensory acceptability of infant cereals with whole grain in infants and young children20179165MadrelleJ.LangeC.BoutrolleI.ValadeO.WeenenH.Monnery-PatrisS.IssanchouS.NicklausS.Development of a new in-home testing method to assess infant food liking2017113274283