Journal of Chemistry

Volume 2013 (2013), Article ID 546839, 6 pages

http://dx.doi.org/10.1155/2013/546839

Research Article

Adsorption Properties of Lac Dyes on Wool, Silk, and Nylon

Bo Wei,¹ Qiu-Yuan Chen,¹ Guoqiang Chen,¹ Ren-Cheng Tang,¹ and Jun Zhang²

¹National Engineering Laboratory for Modern Silk, College of Textile and Clothing Engineering, Soochow University, Suzhou 215123, China

²Suzhou Institute of Trade and Commerce, 287 Xuefu Road, Suzhou 215009, China

Received 24 May 2013; Revised 26 August 2013; Accepted 31 August 2013

Academic Editor: Mehmet Emin Duru

Copyright © 2013 Bo Wei et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract.

There has been growing interest in the dyeing of textiles with natural dyes. The research about the adsorption properties of natural dyes can help to understand their adsorption mechanism and to control their dyeing process. This study is concerned with the kinetics and isotherms of adsorption of lac dyes on wool, silk, and nylon fibers. It was found that the adsorption kinetics of lac dyes on the three fibers followed the pseudosecond-order kinetic model, and the adsorption rate of lac dyes was the fastest for silk and the slowest for wool. The activation energies for the adsorption process on wool, silk, and nylon were found to be 107.15, 87.85, and 45.31 kJ/mol, respectively. The adsorption of lac dyes on the three fibers followed the Langmuir mechanism, indicating that the electrostatic interactions between lac dyes and those fibers occurred. The saturation values for lac adsorption on the three fibers decreased in the order of wool > silk > nylon; the Langmuir affinity constant of lac adsorption on nylon was much higher than those on wool and silk.

1. Introduction

Natural dyes generally exhibit better biodegradability and compatibility with the environment and lower toxicity and allergic reaction [1–3]. In recent years, there has been growing interest in the dyeing of textiles with natural dyes, and a lot of natural dyes from different resources have been explored to be applied in textile dyeing [4]. On the basis of origins, natural dyes are broadly classified into three categories: vegetable, mineral, and animal origins. Animal origin lac, cochineal, and kermes bearing anthraquinone structures have been the principal natural dyes yielding from the insects [5, 6]; these insect red dyes can dye textiles to purple and red colors and have good color fastness to light in comparison with most of vegetable dyes [6, 7]. Up to the present, there have been a lot of published studies about the application of vegetable dyes to the dyeing of textiles [1, 3–5, 7] but relatively few reports about the exploitation of insect dyes in the field of textile dyeing.

Lac dyes (laccaic acid) consisting of polyphenolic anthraquinone compounds are a natural, weakly acidic, and reddish colorant produced by the insect Coccus lacca or Laccifer lacca and can be obtained in large amounts as a by-product of shellac industry [8, 9]. Over the past years, there have been a few studies highlighting the dyeing of lac for cotton and silk [8–10]. Chairat and Rattanaphani reported the adsorption kinetics of lac dyeing on cotton and silk, which have been found to follow the pseudosecond-order kinetic model [9, 10]. However, little research has so far been undertaken on the dyeing of nylon and wool with lac dyes. Taking into consideration the fact that the research about the adsorption properties of natural dyes helps to understand their adsorption mechanism and to control their dyeing process, this study is mainly concerned with the kinetics and isotherms of lac adsorption on wool, silk, and nylon fibers.

2. Experimental

2.1. Materials

The scoured, woven wool fabric (warp and weft thread, 156 dtex×2) for color fastness tests up to the standard GB/T 7568.1-2002 was purchased from Shanghai Textile Industry Institute of Technical Supervision. The scoured, woven silk fabric (warp and weft thread, 23.3 dtex×2) and the scoured, woven semidull nylon fabric (warp thread, 55.6 dtex/48F; weft thread, 50.0 dtex/34F) were obtained from Wujiang Zhiyuan Textile Co. Ltd., China. All of the fabrics were plain woven and used as received.

A commercial lac dye was obtained by Yunnan Tonghai Yang Natural Products Co. Ltd., China. Leveler O used as a leveling agent is the commercial product. Citric acid and disodium hydrogen phosphate used to adjust the pH of dyeing solutions were of analytical reagent grade.

2.2. Adsorption of Lac Dyes

All experiments of adsorption were carried out in sealed conical flasks immersed in the universal dyeing machine. The liquor ratio was 60 : 1.

(1)Adsorption rates. The silk, wool, and nylon fabrics were dyes with 4% owf lac dyes and 0.5 g/L Leveler O at pH 3 and at constant temperature for different times.(2)Adsorption isotherms. The adsorption isotherms for lac dyes on the silk, wool, and nylon fabrics were measured in a series of lac dye solutions of various concentrations (1~21% owf) at pH 3 at 90°C for 80 min.

2.3. Determination of Lac Dye Concentration

At the end of each dyeing, the concentration of lac dyes remained in the dye-bath was determined by reference to the extinction coefficient of a calibration plot of lac dyes at the maximum adsorption wavelength. The absorbance of the dye solution was measured using a Shimadzu 1800 UV/VIS spectrophotometer. The quantity of lac dyes on the fibers was calculated by taking into account the initial and final concentration of lac dyes in solution and the weight of the dried fabrics.

3. Results and Discussion

3.1. Adsorption Kinetics of Lac Dyes

The adsorption kinetics is important as it controls the process efficiency. Figure 1 depicts the effect of time () on the quantity () of the adsorption of lac dyes on wool, silk, and nylon at two temperatures. As shown in Figure 1, the initial rates of the adsorption of lac dyes on silk were the fastest, and the quantity of adsorption reached a very high value in short times, indicating that some measures should be taken to control the levelness of silk dyeing. The initial rate of lac adsorption on wool was the slowest, which can be explained by the poor ability of dye diffusion into wool substrate owing to the tight structure of epicuticle layer existing on wool surface. The rate of lac uptake by nylon was between those of wool and silk.

(a)

(b)

(c)

Figure 1: Adsorption rates of lac dyes for wool, silk, and nylon at 70°C (a), 80°C (b) and 90°C (c).

In this study, the pseudosecond-order kinetic model was used to investigate the adsorption process of lac dyes on three fibers. The pseudosecond-order kinetic model is based on both chemisorption and adsorption equilibrium capacity and can be expressed as follows [11, 12]:

where is the rate constant for pseudosecond-order adsorption and and are the adsorption amounts of lac dyes at time and at equilibrium.

Integrating (1) and applying the initial conditions give

or, equivalently,

and [9, 12]

where is the initial adsorption rate the following:

If the pseudosecond-order kinetics is applicable, the plot of () versus would show a linear relationship. The slope and intercept of () versus were used to calculate the pseudosecond-order rate constant () and the quantity of equilibrium adsorption ().

The half adsorption time () was calculated using the following [13]:

The pseudosecond-order kinetic model was also used to test the experimental data using (3), and the plots of () against for the adsorption of lac dyes on the three fibers are given in Figure 2. The kinetic parameters along with the correlation coefficients () of the kinetic model are shown in Table 1. From Table 1, it is clear that the correlation coefficients for the linear plots were higher than 0.996 for all the experimental data, indicating that the pseudosecond-order kinetic model might be suitable to describe the adsorption process of lac dyes onto wool, silk, and nylon.

Table 1: Kinetic parameters for the adsorption of lac dyes on wool, silk, and nylon.

Temperature (°C)
Fibers
(mg/g)
(min)
( g/[mg·min])
(mg/[g·min])

70
Wool
42.92
22.498
0.104
1.91
0.9968

Silk
30.21
0.737
4.490
40.98
0.9999

Nylon
23.87
3.313
1.265
7.20
0.9992

80
Wool
40.65
7.268
0.339
5.59
0.9971

Silk
27.55
0.457
7.938
60.24
0.9999

Nylon
22.42
2.357
1.893
9.51
0.9998

90
Wool
39.37
3.094
0.821
12.72
0.9993

Silk
25.00
0.163
24.615
153.85
0.9994

Nylon
21.65
1.522
3.036
14.22
0.9987

(a)

(b)

(c)

Figure 2: Plots of against for the adsorption of lac dyes on wool, silk, and nylon at 70°C (a), 80°C (b), and 90°C (c).

As can be seen from Table 1, the kinetic parameters for the adsorption of lac dyes varied according to fiber categories and temperature. For the adsorption of lac dyes on silk, the highest rate constant () and initial adsorption rate () were found with the shortest half adsorption time (), which might be ascribed to the looser surface structure of silk than those of wool and nylon. The adsorption of lac dyes on wool showed the lowest and values with the longest , which could be explained by the existence of the epicuticle layer on the surface of wool and the corresponding barrier action to the diffusion of dyes into fiber interior.

From the rate constant (Table 1), the activation energies () for the adsorption of lac dyes on the three fibers were determined using the following Arrhenius equation [9]:

where , , , and refer to the Arrhenius activation energy, the gas constant, the Arrhenius factor, and the temperature in K, respectively. can be estimated from the slope of the plots of versus shown in Figure 3.

Figure 3: Plots of versus for the adsorption of lac dyes on wool, silk, and nylon.

The calculated activation energies of the adsorption of lac dyes were 107.15 kJ/mol for wool, 87.85 kJ/moL for silk, and 45.31 kJ/mol for nylon, respectively. The physisorption processes usually have energies in the range of 5–40 kJ/moL, while higher activation energies (40–800 kJ/moL) suggest chemisorptions [14, 15]. Therefore, it can be concluded that the adsorption of lac dyes has the characteristic of chemisorptions which is a consequence of the ion-ion interaction between the protonated amino groups in three fibers and the carboxyl groups in lac dyes.

3.2. Adsorption Isotherms of Lac Dyes

The adsorption isotherms of lac dyes on three fibers at 90°C are given in Figure 4. Here, is the concentration of lac dyes in the solution at the end of dyeing. Clearly, within a certain range of concentration, the amount of lac uptake by fibers () increased with increasing concentrations of lac dyes in the solutions. As the increased further, the would approach a maximum value. The adsorption isotherm curves had the characteristics of Langmuir type. As a result, the dyeing mechanism of lac dyes on three fibers could be explained by Langmuir model. The Langmuir affinity constants and saturation values could be calculated according to the following linearity equation of [9, 16] and are listed in Table 2:

where and are the concentrations of lac dyes on fibers and in solution at the end of dyeing, respectively; is the Langmuir affinity constant; is the saturation concentration of dyes on fibers by Langmuir.

Table 2: Langmuir adsorption parameters of lac dyes on wool, silk and nylon.

Fibers
(mg/g)
(mL/mg)

Wool
169.49
6.97
0.9994

Silk
58.14
3.71
0.9984

Nylon
26.60
20.19
0.9789

(a)

(b)

Figure 4: Plots of against (a) and against (b) of adsorption isotherms of lac dyes on wool, silk, and nylon.

It is clear from Table 2 that the values for lac adsorption on the three fibers decreased in the order of wool > silk > nylon, with this being directly relevant to the content of amino groups in the three fibers. Lac dyes showed the much higher Langmuir affinity constant () for nylon than those for wool and silk, which was due to their stronger nonionic interactions with nylon such as van der Waals forces.

4. Conclusions

This study discussed the adsorption properties of lac dyes on wool, silk, and nylon fibers. The adsorption process of lac dyes on the three fibers was in accordance with the pseudosecond-order kinetic model. The adsorption rate of lac dyes was the fastest for silk and the slowest for wool. The activation energies of the adsorption of lac dyes were 107.15 kJ/moL for wool, 87.85 kJ/moL for silk, and 45.31 kJ/moL for nylon, respectively, showing the chemisorption characteristic. The adsorption of lac dyes on the three fibers followed the Langmuir model, indicating that the ion-ion interaction between lac dyes and those fibers occurred. The saturation values for lac adsorption on the three fibers decreased in the order of wool > silk > nylon, with this being directly relevant to the content of amino groups in those fibers. Lac dyes showed the higher Langmuir affinity constant for nylon than those for wool and silk.

Acknowledgments

This study was funded by Jiangsu Provincial Natural Science Foundation of China, Suzhou Research Program of Application Foundation, and the Priority Academic Program Development (PAPD) of Jiangsu Higher Education Institutions.

References

T. Bechtold, A. Turcanu, E. Ganglberger, and S. Geissler, “Natural dyes in modern textile dyehouses—how to combine experiences of two centuries to meet the demands of the future?” Journal of Cleaner Production, vol. 11, no. 5, pp. 499–509, 2003.

E. Tsatsaroni and M. Liakopoulou-Kyriakides, “Effect of enzymatic treatment on the dyeing of cotton and wool fibres with natural dyes,” Dyes and Pigments, vol. 29, no. 3, pp. 203–209, 1995.

A. K. Samanta and P. Agarwal, “Application of natural dyes on textiles,” Indian Journal of Fibre and Textile Research, vol. 34, no. 4, pp. 384–399, 2009.

M. Shahid, Shahid-ul-Islam, and F. Mohammad, “Recent advancements in natural dye applications: a review,” Journal of Cleaner Production, vol. 53, pp. 310–331, 2013.

A. K. Samanta and A. Konar, “Dyeing of textiles with natural dyes,” in Natural Dyes, E. A. Kumbasar, Ed., chapter 3, pp. 29–56, InTech, Rijeka, Croatia, 2011.

E. S. B. Ferreira, A. N. Hulme, H. McNab, and A. Quye, “The natural constituents of historical textile dyes,” Chemical Society Reviews, vol. 33, no. 6, pp. 329–336, 2004.

G. W. Taylor, “Natural dyes in textile applications,” Review of Progress in Coloration and Related Topics, vol. 16, no. 1, pp. 53–61, 1986.

P. Kongkachuichay, A. Shitangkoon, and N. Chinwongamorn, “Thermodynamics of adsorption of laccaic acid on silk,” Dyes and Pigments, vol. 53, no. 2, pp. 179–185, 2002.

M. Chairat, S. Rattanaphani, J. B. Bremner, and V. Rattanaphani, “An adsorption and kinetic study of lac dyeing on silk,” Dyes and Pigments, vol. 64, no. 3, pp. 231–241, 2005.

M. Chairat, S. Rattanaphani, J. B. Bremner, and V. Rattanaphani, “Adsorption kinetic study of lac dyeing on cotton,” Dyes and Pigments, vol. 76, no. 2, pp. 435–439, 2008.

Y. S. Ho and G. McKay, “Pseudo-second order model for sorption processes,” Process Biochemistry, vol. 34, no. 5, pp. 451–465, 1999.

A. E. Ofomaja, E. B. Naidoo, and S. J. Modise, “Kinetic and pseudo-second-order modeling of lead biosorption onto pine cone powder,” Industrial and Engineering Chemistry Research, vol. 49, no. 6, pp. 2562–2572, 2010.

X.-Y. Pang and F. Gong, “Study on the adsorption kinetics of acid red 3B on expanded graphite,” Journal of Chemistry, vol. 5, no. 4, pp. 802–809, 2008.

M. S. Chiou and H. Y. Li, “Adsorption behavior of reactive dye in aqueous solution on chemical cross-linked chitosan beads,” Chemosphere, vol. 50, no. 8, pp. 1095–1105, 2003.

M.-S. Chiou, P.-Y. Ho, and H.-Y. Li, “Adsorption of anionic dyes in acid solutions using chemically cross-linked chitosan beads,” Dyes and Pigments, vol. 60, no. 1, pp. 69–84, 2004.

I. Langmuir, “The adsorption of gases on plane surfaces of glass, mica and platinum,” The Journal of the American Chemical Society, vol. 40, no. 9, pp. 1361–1403, 1918.