Efficiency of the Integrated Nitrogen Removal Device to Remove Ammonia in a Hog House

It is crucial to explore new methods to deal with ammonia pollution in hog barns. In this experiment, ammonia gas generated from the decomposition of nitrogenous organic matter, such as feed and manure in hog barns, was studied. Growing environmental parameters monitored included temperature, humidity, and ammonia nitrogen concentration. For 92 days between March and May, ammonia emissions were characterized by monitoring and collecting the ammonia concentration during the selected time. ,e results showed that the average temperature in the hog house was 18.2± 2.7°C, the humidity was 62.7± 0.3%, and the average ammonia concentration range was 17.7∼23.1mgm. ,e collected ammonia-nitrogen-containing wastewater that entered the denitrification device showed 173, 232, 201, and 280mgNH4-N/L, respectively. An integrated denitrification device with anaerobic ammonia-oxidizing bacteria as a functional strain was used for denitrification treatment. ,rough the change of ion concentration in the incoming and outgoing water, an 85.5% average denitrification efficiency was calculated according to the denitrification reaction chemical formula.,us, the results presented here provide data support for the future use of microbial denitrification equipment to treat ammonia in hog houses.


Introduction
e breeding environment of hogs is directly related to herd health. A good livestock house environment ensures livestock and poultry health, fully utilizes its production performance, and complies with animal welfare requirements. However, due to the rapid development of the large-scale breeding industry, the increasing density of hog farms and the harsh breeding environment have become fundamental problems restricting the development of the large-scale swine industry. e livestock productivity depends 20% on genetics, 40%∼50% on nutrition, and 30%∼40% on environmental conditions [1], where ammonia is one of the leading noxious gases in hog houses. Ammonia in hog houses mainly comes from the anaerobic degradation of organic matter in fresh manure, feed residue, and microbial waste. e ammonia effect on the health of pigs depends on its concentration. When low concentrations of ammonia cause mild poisoning in pigs, its manifestation is not very noticeable; however, it reduces the resistance of pigs and hinders their growth. High ammonia concentrations directly cause pigs to die and affect the health of breeders [2]. erefore, it is essential to pay more attention to ammonia, take measures to timely and effectively control the ammonia concentration in hog houses, and optimize the air quality of the hog house to maintain the health of pigs and promote production. At present, most research focuses on mechanical ventilation [3]. Although directly exhausting the turbid air from hog houses by ventilation is the most direct and effective method to reduce the ammonia concentration, it does not fundamentally solve the emission reduction of ammonia, which will react with oxides in the air to generate secondary particles such as ammonium sulfate and ammonium nitrate. ese secondary particles are an important source of PM2.5 formation. In summary, how to remove the ammonia produced by the livestock breeding process is the fundamental problem to be solved.
ere are three aspects in controlling and treating ammonia pollution in animal husbandry: source prevention and control, emission reduction in the breeding process, and end treatment. More well-established research on controlling nitrogen emissions at the feed source can be adjusted through the entire diet stage, and standards have been established. Various feed additives that meet the production needs have been developed, yet the research continues on cost-effective and nonresistant additives. Emission reduction in the feeding process is closely related to feeding management, and it is difficult to unify standards and requirements for all farms. e end treatment of ammonia has excellent potential in the environmental protection of aquaculture, and the emission reduction effect is also rather satisfactory, which is the general trend of ammonia emission reduction in the future. e main technical challenge of ammonia end treatment is maintaining the emission reduction effect at a higher load rate, increasing the biofilter medium's service life, and increasing the abundance and number of microorganisms in the biofilter medium.
e Labfors fermenter in this experiment is an integrated denitrification device, which occupies a small area and contains a probe that can be flexibly configured according to the required measurement data. e open-air path makes it suitable for microbial cultivation, high-density cultivation, and anaerobic culture. It has also been used in nitrogen and phosphorus removal research and tailgas collection and analysis, but no research has been performed on the ammonia removal in swine houses.
is study selected the temperature, humidity, and ammonia concentration of the pig growing environment as the main environmental parameters for monitoring. Ammonia concentration monitoring was conducted for 100 days, ammonia emission characteristics were analyzed, and the main environmental factors affecting ammonia emissions were comprehensively evaluated. Based on the performance of the integrated denitrification unit to effectively remove ammonia nitrogen wastewater, the ammonia gas collected in the hog house was passed to the integrated denitrification unit. e reactor parameters and NH + 4 , NO − 2 , and NO − 3 concentration changes in the inflow and effluent were monitored, and the denitrification efficiency of the device was optimized based on the stoichiometric method.

Hog House
Layout. An experimental hog house in Changchun City was selected as the test site. e hog house was a double-slope windowed structure 40 m in length, 12 m in width, and 3 m in height. e columns were arranged in two rows and a single walkway in the middle of the hog house. e test hog house was equipped with a storage room, a feeding area, and a tower. Figure 1 shows the layout of the hog house. Two ammonia sampling points (A/B) were set in the middle of the hog house corridor, and the ammonia concentration at this point was calculated as the emission concentration. An atmospheric sampler (FCC-1000H, Yancheng Tianyue) was used to collect gas samples. e height of the sampler is 1.2 m above the ground, and the sampling flow rate is 100 L h −1 . During the experiment, 190 pigs in the fattening hog house, aged about 100 days, were fed daily at 8:30 and 16:30.

Temperature and Humidity Collection.
e fattening hog house used mechanical ventilation with an automatic temperature sensor controlling the fan operation. Temperature and humidity data collectors (RS-YS-GPRS-B) placed at both ends and along the middle aisle of the longitudinal axis of the hog house automatically collected the temperature and relative air humidity at 10 min intervals.

Integrated Denitrification Device.
A Labfors bench fermentation tank composed of a tank body and a host served as the experimental reaction device ( Figure 2). e host can use IRIS software to adjust the reactor parameters remotely, including stirring speed, temperature, pH, DO, and gas mixing ratio. e Environmental Engineering Laboratory of Suzhou University of Science and Technology provided the functional microorganism which was anaerobic ammoniaoxidizing bacteria. After 400 days of stable denitrification, the denitrification effect is good. During this experiment, the working volume of the bioreactor was 4.5 L, the working temperature of the reactor was 30°C, and the pH was 7.5 ± 0.5. For intermittent aeration, a mechanical agitator in the fermentation tank was used for the disturbance at a speed of 70 rpm with an airflow of 0.7-1.2 L/min during the aeration stage.

Determination Method of Ammonia Concentration.
Determination of ammonia nitrogen was performed according to the "Ambient Air and Exhaust Gas-Determination of Ammonia-Nessler's Reagent Spectrophotometry" Standard (HJ 533-2009). Briefly, 10 mL of 0.01 mol·L −1 sulfuric acid absorption solution was prepared in the lab and added into the absorption tube. e mouth of the tube was sealed and sent to the experimental pig farm. e air in the hog house was collected at a flow rate of 100 L h −1 for 1 h. After sampling, the nozzle was sealed and returned to the laboratory. e sample analysis was completed on the same day. Simultaneously, blank parallel samples were tested throughout the process.

Ammonia Emission Measurement.
Combining the sampling time point and the fan running time, in this experiment, the hog house management activity time (7:00-17: 00) was divided into 5 sampling periods (7:00-9:00, 9:00-11: 00, 11:00-13:00, 13:00-15:00, and 15:00-17:00). e total amount of ventilation per period was multiplied by the corresponding ammonia concentration averages at 8:30, 10: e sum of the ammonia concentration averages represents the ammonia emissions during the day. On this basis, the ammonia emission at night was calculated by the night ventilation and ammonia concentration at 8:30, and the ammonia emission factor in the hog house was further calculated (E factor , g·h·m 2 ) [4]: where Q j is the total ventilation of the hog house during the j period in m 3 ; C ji is the ammonia concentration in hog house in mg·m −3 ; C jo is the ammonia concentration in the atmosphere in mg·m −3 ; A is the area of the hog house in m 2 ; and t is the time length of the j-th period in h.

Configuration of Ammonia Collection Solution.
During the 92 days of the experiment, ammonia gas was collected every half a month a total of 4 times, and each sampling lasted for 7 days. Ammonia has a high solubility in water; thus, it was collected with a stock solution lacking only NH

Inlet and Outlet Water Concentration Measurement.
An ion-selective electrode (Labfors 3.6 L) measured the NH 4 -N and NO 3 -N concentrations in the incoming and outgoing water. e data were recorded online, and the specific data in operation in the IRIS online data acquisition system were selected. e NH 4 -N and NO 3 -N concentrations were also measured offline three times a week on average, and the online measured values were compared and calibrated.
roughout the experiment, the NO 2 -N concentration was only measured offline with a colorimetric detection kit (BesetBio-470571). e chemical reaction would change the color intensity based on the concentration, and an ultraviolet spectrophotometer (722G-Jingke Shangfen) measured the concentration value. e denitrification efficiency was calculated using the measured changes in the inflow and outflow water concentration according to the stoichiometry equation (2) for autotrophic denitrification reactions.

Relationship between Ammonia Concentration and
Temperature and Humidity in the Hog House. e livestock house environmental conditions mainly refer to the environmental temperature, relative humidity, light intensity, airflow speed, and air quality. Environmental temperature is an important factor affecting the normal production and life of pigs. Pigs are thermostatic animals that maintain body temperature within a specific range through heat production and heat dissipation [5]. e suitable temperature for fattening pigs differs by growth stages [6]. e suitable temperature for adult pig growth is 15∼25°C, and heat stress will occur if the temperature exceeds 35°C. However, the suitable temperature for the newborn piglets is 34°C and then decreases 2°C every week, reaching 22∼25°C at weaning. e suitable relative humidity (RH) is about 50%, and the ammonia concentration should be kept below 20 mg m −3 [7][8][9][10][11]; otherwise, bacteria proliferate in hog houses, and pigs get sick relatively quickly. Humidity is another important environmental factor affecting the healthy growth of pigs. Studies have shown that when the humidity in the hog house is too low (<40%), the dust in the house can easily float in the air, inducing respiratory infections and causing respiratory diseases. Table 1 shows the daily average temperature and relative humidity during the 100 d of the experiment. Of the two ammonia sampling points (A/B) in Figure 1, the point with the least deviation from the average was chosen and given the shoulder mark. e humidity in the hog house changes regularly every day, and the range of humidity changes is within the comfort range of pigs, consistent with previous studies [5]. Reports on livestock house humidity monitoring during summer showed that the fan running continuously for a long time maintained a low temperature, reducing humidity accordingly. Vanderstelt et al. [12] also reported that the temperature in the growth and fattening house showed noticeable daily rhythm changes in all seasons, with temperatures first increased and then decreased within a day. In spring and winter, the humidity standard error in the barn is relatively small, although there is a rather significant difference in humidity in the barn in spring. e higher ammonia volatilization in winter may be related to the dry matter content of manure in the house, the main characteristic factor affecting the volatilization of manure ammonia. Figure 3 shows that, in the 92 days of spring, the temperature in the house varies from 14.5 to 21.9°C, and the humidity varies from 59.7-67.7%. e overall change is increasing due to the increase in outdoor temperature. e "Environmental Parameters and Environmental Management of Large-scale Pig Farms" (GB/T 17824.3-2008) promulgated by China in 2008 stipulates that the comfortable humidity for pregnant sow houses ranges from 60 to 70%, whereas that of growing and finishing houses is 60-75% [13]. e ammonia in hog houses comes from pig manure, and its production and discharge are affected by many factors, such as manure cleaning, feeding management, manure characteristics, environmental temperature, manure composition, and ventilation [12,14]. e temperature in the hog house is maximized in summer (4∼7°C) higher than that in other seasons, followed by spring. Spring is characterized by the highest humidity [4]. e possible reason for the positive correlation between ammonia concentration and humidity is that ammonia is highly soluble in water, so when the humidity is high, the air holds much ammonia; hence, the ammonia concentration is relatively high.

Ammonia Concentration in the Hog House.
Measurement statistics show that, in most small-and medium-sized pig farms in China, especially in closed barns, ammonia concentrations range from as low as 6-35 mg-m −3 to as high as 150-500 mg-m −3 , far exceeding the permissible concentration of ammonia in pig farms in China (25 mgm −3 ) [2]. Figure 4 shows the monthly change in ammonia during the test period. e average daily ammonia concentration in the hog house is 17.7-23.1 mg m −3 , which does not exceed the GB/T Figure 4, the highest ammonia concentration in the hog house in other months peaked at 8:30, while the lowest value appears at 12:30. At the same time point, the ammonia concentration does not vary significantly, and the daily variation of ammonia concentration in the pig barn is related to the ventilation in the barn. e ventilation rate at night in the hog house is low, and the ammonia concentration accumulates. Because the concentration is the highest at 8:30 and there is ventilation in the house afterward, the ammonia concentration decreases. e reduction in ammonia concentration in the house is related to the manual removal of manure. Zhang [15] studied that, for naturally ventilated and free intake of fattening hog houses, the ammonia concentration in the house dropped sharply after the first manure removal as the floor was washed after dry manure removal. Zhu et al. [16] studied that the ammonia concentration increased significantly after the first manure removal in natural ventilation and artificial feeding and fattening hog houses (P < 0.05). e reason is that the first feeding and manure removal is at the same period, which may also be related to whether the floor is washed after manure removal. In large-scale breeding farms, the ammonia concentration is lower in hog houses with better mechanical ventilation, such as the mechanical ventilation in fattening hog houses (3 months old fattening 91 d) reported by Wu et al. [17] studied with an ammonia concentration of 6.24 mg m −3 . e high ventilation frequency reduces the ammonia concentration in the hog house. Wu et al. [18] studied that the average ammonia concentration in mechanically ventilated fattening barns was 14.2 mg m −3 , and the ventilation of the barn in the early fattening stage was relatively small. Liu et al. [4] determined that the ammonia concentration range in the pigsty was 1.6∼10.0 mg m −3 , but when the fan fails, the sampling point ammonia concentration reaches about 40 mg m −3 , exceeding the standard limit value of 25 mg m −3 . Zhu et al. [16] showed that the ammonia concentration during summer in a semienclosed fattening hog house in Jiangsu is 9-10 mg m −3 . e higher ammonia concentration in this hog house may be related to the stocking density and the age of the fattening pig during the experiment.

Ammonia Emission Rate in the House.
Studies showed that ammonia volatilization in feces and urine increases with temperature. When the environmental temperature increased from 4 to 20°C, ammonia volatilization increased by 3.6∼5.8-fold [12]. e full-day ammonia emission value was the highest in summer, followed by winter. e reason was related to the higher temperature and greater ventilation in the hog house in summer. e increased ventilation is also conducive to the volatilization of ammonia in the blister manure tank, thereby increasing the ammonia emissions [19]. Ranbeeck et al. [20] used a multipoint gas sampler to continuously monitor the H 2 S and CH 4 in the nursery hog house. Li et al. [21] used multipoint continuous gas sampling in a mechanically ventilated cow house to monitor CH 4 emissions continuously for a long time, and the system's accuracy was within 4.5%. Dai et al. [22] used a 1412i gas analyzer and 1309 multichannel gas sampler to determine the emission rates of CH 4 and NH 3 in natural ventilated dairy houses. Tremblay and Masse [23] used multipoint continuous sampling to determine the odor emission of hog houses. Some scholars proposed that the multichannel gas collector could deliver multipoint gas samples to the gas analyzer, greatly facilitating the continuous monitoring of pollutants. However, the collector cost was high, not conducive to popularization and application [3]. In this project, the air sampler FCC-1000H was used for gas collection.
As shown in Figure 5, the ammonia emission rate in the fattening hog house between March and May was 1.92∼2.72 g h −1 m −2 , while the daily average ammonia emission rate was 1.51∼2.61 g h −1 m −2 . Studies have shown that ammonia emission rates from fattening pigs progress from high to low in summer, winter, spring, and autumn. It has been reported that the average atmospheric ammonia concentration from January to July is 10-40 µm m −3 . e highest is in autumn, followed by summer, and the lowest is in spring, with 0.02 mg m −3 [14,24]. erefore, the ammonia concentration 0.02 mg·m −3 was selected for calculation as the atmospheric environmental background value. e research results of [4] show that the ammonia emission rate was 0.17∼0.24 g h −1 m −2 , suggesting that higher emissions during the day might be related to the activities of pigs. Jacobson et al. [25] reported that the daily discharge rate of 12 h ammonia in the deep manure pit fattening hog house was 0.22∼0.61 g h −1 m −2 , and its higher discharge was because the storage time of feces and urine in the manure pit was longer than the storage period of the experimental pig house (two months).

Denitrification Energy Efficiency of the Integrated Device.
In this test, ammonia was collected from the house for seven consecutive days after obtaining the ammonia concentration and emission rate to ensure the influent concentration of the integrated unit in the future. e functional microorganism in the integrated denitrification device was anaerobic ammonia-oxidizing bacteria. e device maintained a pH of 7.5 ± 0.5 and a temperature of 28 ± 2°C. For intermittent aeration, a mechanical agitator in the fermentation tank was used for the disturbance at a speed of 70 rpm with an airflow of 0.7-1.2 L/min during the aeration stage. e solution in the gas collection device gas passed into the device for denitrification treatment. e influent concentrations of the four samples were 173, 232, 201, and 280 mg NH 4 -N/L, respectively. Online monitoring and offline experiments were used, and a sampling test was performed every 15 min. During the operation, the various parameter indicators of the integrated device were controlled based on the denitrification reaction equation (2). e denitrification efficiency of the device was obtained through the change of the nitrogen ion concentration.
As shown in Figure 6, the four concentration change trends are the same, and the denitrification processes take 375, 405, 450, and 495 min, respectively. e concentration of NH + 4 shows a downward trend with time and begins to stabilize in the last hour. e concentration of NO − 3 also shows an upward trend with time and stabilizes in the last half an hour. e concentration of NO − 2 is below 1 mg-N/L,     most of which is 0∼0.5 mg-N/L. e nitrogen removal efficiency is 86.5%, 85%, 82.7%, and 87.9%, respectively, and the average nitrogen removal rate of the reactor is 85.5%. It can be seen that the reactor has a good nitrogen removal efficiency. It is feasible to remove ammonia gas in a hog house by this method.

Conclusions
In this experiment, the temperature, humidity, ammonia concentration, and emission rate in the hog house were monitored to study the monthly changes in the environmental indicators.
e results showed that the average temperature and humidity in the test house were18.2 ± 2.7°C and 62.7 ± 0.3%, respectively. e possible reason for the positive correlation between ammonia concentration and humidity is that ammonia is readily soluble in water, and with high humidity, the air retained much ammonia; hence, ammonia concentration was relatively high. e hog house ammonia concentration during the daytime management activities was 17.7-23.1 mg m −3 , which did not exceed the GB/T 17824.3-2008 (25 mg m −3 ) limit, and the ammonia emission rate was 1.92∼2.72 g h −1 m −2 . Ammonia in the house was collected and passed to the integrated denitrification device with influent concentrations of 173, 232, 201, and 280 mgNH 4 -N/L, respectively. After running for 375-495 min, the final average denitrification efficiency reached 85.5%. e ammonia removal from swine barns with an integrated denitrification unit showed positive lab test results, providing data to support ammonia microbial denitrification devices for ammonia removal in swine barns. Future research directions should aim at the collection and processing of ammonia in swine houses. Jilin Province is an agricultural province, and it can promote the removal of ammonia in other livestock breeding houses within this province, which is conducive to the growth, development, and reproduction of livestock and poultry and improve the breeding efficiency.

Data Availability
e experimental data used to support the findings of this study are included within the article.