Journal of Food Quality
Volume 2019 (2019), Article ID 1715946, 8 pages
https://doi.org/10.1155/2019/1715946

Research Article

Application of Gelatin Incorporated with Red Pitaya Peel Methanol Extract as Edible Coating for Quality Enhancement of Crayfish (Procambarus clarkii) during Refrigerated Storage

Wenru Liu,1,2,3 Yong Shen,1,2,3 Na Li,1,2,3 Jun Mei,1,2,3 and Jing Xie1,2,3

¹Shanghai Engineering Research Center of Aquatic Product Processing & Preservation, Shanghai Professional Technology Service Platform on Cold Chain Equipment Performance and Energy Saving Evaluation, Shanghai 201306, China
²National Experimental Teaching Demonstration Center for Food Science and Engineering, Shanghai Ocean University, Shanghai 201306, China
³College of Food Science and Technology, Shanghai Ocean University, Shanghai 201306, China

Correspondence should be addressed to Jun Mei; delightmay@hotmail.com and Jing Xie; jxie@shou.edu.cn

Received 25 March 2019; Revised 16 June 2019; Accepted 7 July 2019; Published 2 September 2019

Guest Editor: Karolina Kraśniewska

Copyright © 2019 Wenru Liu et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract.

China is one of the largest producers of red pitaya in the world and responsible for disposal of the huge amount of peel generated as a waste. The objective of this research was to evaluate the effect of the addition of red pitaya peel extract (RPPE, 1.0%, 2.0%, or 3.0% (w/v)) and 0.1% ε-polylysine (ε-PL) to a fish gelatin edible coating on the preservation of deshelled crayfish (Procambarus clarkii) during refrigerated storage. The physicochemical and water migration of the samples were determined during 8-day storage. Deshelled crayfish packaged in edible coatings exhibited significantly () lower values for total volatile basic nitrogen (TVB-N), K value maintenance, and free amino acids (FAAs). This study shows that application of an edible coating incorporated with RPPE and ε-PL is an effective strategy in retarding the quality deterioration in deshelled crayfish during storage.

1. Introduction

Crayfish (Procambarus clarkii), with high protein and low fat, is a freshwater economic shrimp in China [1]. In 2016, the total crayfish output was about 90 million tons. Crayfish are usually shucked so that they can be sold as ready-made raw meat, which is more acceptable to consumers and meets the needs of the freshwater product industry [2]. However, crayfish are highly susceptible to microbial infection after shucking and they are not easy to preserve [3]. Free amino acids and other soluble non-nitrogenous substances in crayfish serve as digestible nutrients for microbial growth [4], and this causes a loss in freshness and lowers the quality of the product, causing a market loss of crayfish. Therefore, the development of storage methods that reduce or delay the loss of freshness is important to the crayfish industry.

Pitaya, belonging to Cactaceae family, is a native fruit from Mexico and Central and South America [5, 6]. Red pitaya peel is considered a waste of the processing and represents 33% of the fruit total weight [7]. Red pitaya peel (RPP) is abundant in antioxidant compounds and has an important antioxidant potential [8], which could ensure the chemical stability of deshelled crayfish during refrigerated storage. Pitaya peel is a residue of fruit consumption and processing [9]. In an era of great concern with environmental problems, food by-product valorization and application of green extraction processes have gained much attention [10]. Extracting the active ingredient from the peel can improve the utilization of the peel. Meanwhile, peel extracts are commonly used as biological preservatives in many food processes, especially in the aquatic product, to prolong shelf life including essential oils from tangerine peels and mango peel extracts and polyphenols from apple peels [6, 11, 12]. Edible coating can be used to protect phenolic compounds from oxidation by external factors such as the presence of light, oxygen, metal ions, pH, and high temperatures [13] and provide fresh food protection to prevent quality loss and weight loss. Several researchers have applied it to the storage of aquatic products [14–16].

In this study, we investigated the effect of the addition and the level (1.0%, 2.0%, and 3.0% (w/v)) of red pitaya peel extract (RPPE) combined with 0.1% ε-PL on the physicochemical and water migration of deshelled crayfish stored at 4°C under aerobic condition.

2. Materials and Methods

2.1. Preparation of RPPE

Fresh red pitaya fruits were obtained from the producer in Zhanjiang, China, and the peel was manually separated, lyophilized for 48 h, and milled in a commercial blender (WBL1022S, Guangdong Midea Electric Appliances Co., Ltd, China). The fine powder sifted through a 40-mesh sieve was collected and stored in an amber flask. The powder (25.0 g) was mixed with 200 mL of methanol and water (80 : 20, v/v) solution and then transferred to an ultrasonic extractor (KQ-100DE, Kunshan Ultrasound Instrument Co., Jiangsu, China) at a power of 240 W for 30 min. After extraction, the solution was centrifuged at 3100 × g for 15 min at 4°C, and the supernatant was transferred to an amber flask. The extract was concentrated using a rotary evaporator (RE-5299, Shanghai Yarong Biochemical Instrument Factory, Shanghai, China) at 50 rpm and 40°C under vacuum to remove methanol and then freeze-dried. The freeze-dried RPPE powder samples were stored at 4°C in the dark [8].

2.2. Determination of Polyphenols of RPPE

2.2.1. Total Polyphenolic Content

The total polyphenolic content was determined by the Folin–Ciocalteu colorimetric method based on oxidation/reduction reactions of phenols, and the results were expressed as milligram gallic acid equivalent per gram dry weight (mg·GAE/g·dw) of RPPE powder [17].

2.2.2. Determination of Betacyanin Content

The absorbance of betacyanin was determined using the method described by de Mello et al. [18]. Quantification of betalains was calculated by the following equation:

where A is the absorption value at 538 nm; DF is the dilution factor; MW is the molecular weight of betanin (550 g/mol); is the pigment solution volume (mL); ε is the molar extinction coefficients of betanin (60,000 L·mol⁻¹·cm⁻¹); L is the path length of the cuvette; and W is the weight of pigment powder (g).

2.3. Extraction of Salmon Skin Gelatin

This method described by Tkaczewska et al. [19] was used with some modifications. The salmon skins were cut into small pieces (5 × 5 cm) and poured into water to remove adhesive impurities and soaked in 0.05 mol·L⁻¹ sodium hydroxide for 2 h at a sample/alkali solution ratio of 1 : 6 (w/v). Then, skins were washed with distilled water at 4°C until neutral to remove the remaining alkali, soaked in 0.05 mol·L⁻¹ acetic acid for 2 h at a sample/acid solution ratio of 1 : 6 (w/v), and then also washed to neutrality at 4°C. The pretreated skins were extracted with distilled water at 50°C for 6 h, and the mixture was filtered and then lyophilized to obtain the gelatin sample.

2.4. Preparation of Preservative Solutions

Gelatin solution (1.2%, (w/v)) was prepared by dispersing gelatin in distilled water at 60°C and stirring for 3 h. After dissolved completely, the solution was filtered with cheesecloth and then 0.1% ε-PL was added and the mixture was homogenized at 30k rpm for 60 s. All the edible coating solutions (G: gelatin solution containing 0.1% (w/v) ε-PL; G-1% RPPE: gelatin solution containing 0.1% (w/v) ε-PL and 1% RPPE; G-2% RPPE: gelatin solution containing 0.1% (w/v) ε-PL and 2% RPPE; G-3% RPPE: gelatin solution containing 0.1% (w/v) ε-PL and 3% RPPE) were prepared and adjusted to pH 7.0. Finally, a vacuum pump was applied to remove air bubbles from the solutions.

2.5. Determination of Antioxidant Activity of Preservative Solutions

The antiradical activities of preservative solutions were determined using the stable radical DPPH (2,2 diphenyl-1-picrylhydrazyl) according to Mansour et al. [20]. The ABTS (2,2′-azino-bis(3-ethylbenzothiazoline-6-sulphonic acid)) radical-scavenging activity was conducted using the method described by Zhou et al. [21]. The antioxidant capacity of the sample was expressed in terms of the molar concentration of the standard.

2.6. Preparation and Treatment of Crayfish Samples

Fresh red swamp crayfish (Procambarus clarkii) in the same size (9.5 ± 0.3 cm) were purchased from Luchaogang fresh market, Shanghai. Crayfish were transported in a foam-padded box with ice to the lab in 2 hours. Then, the crayfish were cleaned with ice water, the heads and shells were removed, and then they were washed with ice distilled water. The deshelled crayfish were randomly assigned to the five following batches: (1) uncoated (control, CK); (2) treated with gelatin solution containing 0.1% (w/v) ε-PL without RPPE (T0); (3) treated with gelatin solution containing 0.1% (w/v) ε-PL with 1% RPPE (T1); (4) treated with gelatin solution containing 0.1% (w/v) ε-PL with 2% RPPE (T2); (5) treated with gelatin solution containing 0.1% (w/v) ε-PL with 3% RPPE (T3). The deshelled crayfish were individually coated by immersing in the edible coating for 60 s (ratio of coating solution to crayfish, 5 : 1), and then, the coated samples were removed and allowed to drain at 4°C for 20 min to form the edible coatings. The control samples were dipped in sterile purified water as other coating solutions for 1 min and then drained at 4°C. The treated crayfish samples were then packed in polyethylene bags and stored at 4 ± 0.5°C for 8 days. The experimental design is shown in Figure 1. Physicochemical and water migration analyses were performed at 0, 2, 4, 6, 7, and 8 days of storage to study the progress of deterioration.

Figure 1: Application of gelatin-based edible coating containing red pitaya peel methanol extract on deshelled crayfish at day 0.

2.7. Physicochemical Analysis

2.7.1. pH and Conductivity Measurement

The pH measurement and conductivity were determined according to Kim et al. [22] using the pH meter (PB-10; Sartorius, Germany) and conductivity meter (FE30; Mettler Toledo, Shanghai, China).

2.7.2. K Value

The K value was determined according to Fang et al. [23].

2.7.3. Determination of Total Volatile Basic Nitrogen (TVB-N)

The TVB-N values were determined according to Shi et al. [24], and the TVB-N values of crayfish samples were expressed in mg N/100 g.

2.7.4. Determination of Free Amino Acids (FAAs)

The FAAs were measured by the method according to Yu et al. [25] using the automatic amino acid analyzer (L 8800; Hitachi Ltd, Japan).

2.8. LF NMR Analysis

LF NMR analysis was performed according to the method of Li et al. [26]. Portions of 0.5 × 0.5 × 0.2 cm (about 1 g) were cut from the dorsal part of crayfish and sealed with polyethylene films. The samples were placed in NMR tubes (70 mm diameter). T₂ measurements were recorded on a LF NMR analyzer (MesoMR23-060H.I, Newmai co., Ltd., CA) with a proton resonance frequency of 20 MHz, and the primary parameters were as follows: SW = 100 kHz, RFD = 0.08, NS = 4, , , RG1 = 20 dB, DRG1 = 6 dB, PRG = 0, delay DL1 = 0.2 ms, and TW = 2000 ms. Longitudinal relaxation T₁ was measured by using the inversion-recovery sequence by the following parameters: , , SW = 200 KHz, RFD = 0.020 ms, RG1 = 20 dB, DRG1 = 1, NS = 4, TW = 5,000 ms, PRG = 0, NTI = 20, and DL1 = 0.2 ms.

2.9. SEM

Pieces of 3.0 × 5.0 mm muscle tissue were cut from the sample, fixed with 2.5% glutaraldehyde for 2 h at 4°C and then washed with phosphate buffer (pH 7.2) three times. Gradient elution with 50, 70, 80, 90, 95, and 100% ethanol was performed for 15 min, respectively. Microstructure observations of surface were carried out using a SEM S-3400N (Hitachi, Japan).

2.10. Statistical Analysis

The one-way ANOVA procedure followed by Duncan’s multiple range tests was adopted to determine the significant difference () among treatment means, and the results were expressed as means ± SD.

3. Results and Discussion

3.1. Antioxidant Activity of Preservative Solutions

The total phenolic contents of RPPE were 4534.78 mg of GAE/100 g of RPPE, and the betanin presented 55.85 mg/100 g. The DPPH radical scavenging was 18.14%, 24.19%, 31.81%, and 38.54% for T0, T1, T2, and T3 solutions, respectively. These results demonstrated that the higher RPPE addition showed a higher antioxidant activity in the coating solutions. This behavior was also observed where the samples containing with higher RPPE addition presented higher values of antioxidant activity. The ABTS radical scavenging for edible coatings solutions with 1%, 2%, and 3% RPPE was 0.19, 0.32, and 0.39 mM Trolox equivalent, respectively, and the CK and T0 had no antioxidant activity. This was similar to the result of DPPH radical scavenging in pomegranate peel extract- (PPE-) incorporated zein film [27]. The DPPH radical scavenging was about 40% for film-25 mg PPE. RPPE may be a good substitute for synthetic antioxidants, and the results also demonstrated that the RPPE presents antioxidant activity when added to the edible coating solutions.

3.2. pH and Electrical Conductivity Analysis

The changes in pH of crayfish are shown in Figure 2(a). The initial pH value was 6.65, and it is similar to that of white shrimp [28]. The pH of CK and T0 samples significantly decreased () at first and then increased from day 2 to the end. However, the pH of T1, T2, and T3 samples significantly decreased () from day 0 to day 4 and then tended to increase. The decrease in pH may due to the lactic acid produced by the glycolysis of glycogen [29]. During refrigerated storage, the volatile compounds such as trimethylamine, dimethylamine, and ammonia produced by proteolysis led to the increase of pH [30]. This result was consistent with the result of Wang et al. using chitosan-carvacrol coating on the quality of Pacific white shrimp during iced storage [31]. Electrical conductivity is an index of the concentration of electrolytes in the muscle tissue, and it can be used to characterize the texture of sample tissue [32]. The electrical conductivity value of all samples increased significantly (), while the CK and T0 samples showed higher values during storage (Figure 2(b)). The RPPE could slow the electrical conductivity increase, which may be due to ionic substances produced by bacteria and decomposed muscle tissues [33].

(a)

(b)

(c)

(d)

Figure 2: Change in pH values, electrical conductivity, TVB-N, and K value of crayfish during storage at 4°C.

3.3. TVB-N Analysis

TVB-N value could assess the quality of freshwater products during storage, and its increase is closely associated with the degradation of protein or nonprotein nitrogenous compounds by the activities of spoilage bacteria and endogenous enzymes [34]. The TVB-N value of deshelled crayfish at day 0 was 4.58 mg/100 g, and it continually increased in all the samples during storage (Figure 2(c)). The CK showed significantly higher values than T1, T2, and T3 (). Generally, 20 mg/100 g is the rejection limit for TVB-N values in freshwater products [35], and the TVB-N value in CK and T0 reached to an unaccepted level (31.13 mg/100 g and 20.32 mg/100 g, respectively) at day 6. Samples with bioactive edible coating containing RPPE had lower TVB-N values compared with CK and T0. T1 reached the unaccepted level at day 7, and T2 and T3 reached the unaccepted level at day 8. The RPPE could delay the increase of TVB-N effectively, leading to a longer shelf life of deshelled crayfish. This is in agreement with the research reported by Morsy using pomegranate peel to improve the quality attributes of meatballs [36].

3.4. K Value Analysis

K value is an effective and reliable index for freshness evaluation of freshwater products [11]. The initial K value in samples was 6.13% (Figure 2(d)), and a gradual increase in K value was observed with storage time, which suggested that fish gelatin edible coating containing RPPE could keep the freshness in crayfish muscle during storage. The K value of all samples increased significantly (), while the CK showed higher values during storage. The K value in CK, T0, T1, T2, and T3 exceeded 70% (considered to be unacceptable [37]) after 6, 7, and 8 days of storage, respectively. This result was similar to the shelf life extension of crucian carp using natural preservatives during chilled storage [38].

3.5. LF-NMR

NMR transverse relaxation T₂ indicates three different types of water, which are as follows: the bound water entrapped within tertiary and quaternary protein structures, immobile water within the myofibril, and free water in the extramyofibrillar space, corresponding to T₂₁ (0.01 to 10 s), T₂₂, (10 to 100 ms), and T₂₃ (100 to 1000 ms), respectively [24]. Furthermore, the integral area of different transversal relaxation times in the percentage of the total integral area could reflect the content of different forms of water [39]. In the research, T₂₁ changed slightly for all the samples; however, T₂₂ decreased and T₂₃ fluctuated without regular trends during storage. This result indicated that the changes of free water were more obvious than those of bound and immobile water in deshelled crayfish samples with the storage time. , , and corresponded to the areas of relaxation times T₂₁, T₂₂, and T₂₃ (Table 1). Obviously, and increased observably; however, diminished progressively during storage, and took the largest proportion of three types of water. No significant differences () was detected among the immobilized water in T3 compared with other samples, probably due to that more RPPE addition could retard the immobilized water within the myofibril to free water and keep excellent quality of crayfish muscle.

Table 1: Changes of transverse relaxation time and water distribution of crayfish during storage.

Storage time (day)
T₂₁
T₂₂
T₂₃

0d

0.75 ± 0.05abc
65.79 ± 2.63a
464.16 ± 19.28a
1.14 ± 0.01ab
97.58 ± 0.04a
1.28 ± 0.01ab

2d

CK
1.32 ± 0.04de
65.79 ± 2.63a
533.67 ± 37.36b
1.05 ± 0.01bc
96.38 ± 0.09b
2.57 ± 0.07c

T0
1.32 ± 0.05de
75.65 ± 6.05b
705.48 ± 28.22c
1.24 ± 0.04ad
97.04 ± 0.03c
1.72 ± 0.07de

T1
1.34 ± 0.43de
75.65 ± 2.27b
533.67 ± 48.03b
0.99 ± 0.08c
97.39 ± 0.02d
1.62 ± 0.09e

T2
1.14 ± 0.49ef
65.79 ± 1.97a
464.16 ± 4.52a
1.30 ± 0.01de
97.25 ± 0.04e
1.45 ± 0.09f

T3
0.76 ± 0.02abc
75.65 ± 1.51b
738.20 ± 21.45c
1.41 ± 0.09f
97.24 ± 0.04e
1.35 ± 0.04a

4d

CK
1.52 ± 0.14dg
57.22 ± 3.87c
403.70 ± 32.30ae
2.43 ± 0.09g
95.04 ± 0.08f
2.53 ± 0.05c

T0
1.52 ± 0.09dg
65.79 ± 3.95a
533.67 ± 48.03b
1.85 ± 0.04h
96.25 ± 0.03g
1.90 ± 0.05g

T1
1.04 ± 0.08aef
57.22 ± 0.51c
464.16 ± 13.92a
2.33 ± 0.08i
96.16 ± 0.06g
1.51 ± 0.04f

T2
1.14 ± 0.25ef
65.79 ± 3.29a
464.16 ± 4.55a
1.24 ± 0.10ad
97.53 ± 0.09a
1.23 ± 0.07b

T3
0.72 ± 0.07abc
57.22 ± 2.86c
351.12 ± 24.58e
1.38 ± 0.07ef
97.49 ± 0.03a
1.13 ± 0.08h

6d

CK
0.43 ± 0.01c
49.77 ± 0.98d
403.70 ± 16.15ae
2.07 ± 0.03j
94.57 ± 0.03h
3.37 ± 0.04i

T0
1.34 ± 0.27de
75.65 ± 7.52b
613.59 ± 36.82d
1.86 ± 0.05h
95.62 ± 0.04i
2.51 ± 0.02c

T1
0.87 ± 0.02abf
57.22 ± 1.72c
533.67 ± 36.70b
2.08 ± 0.07j
95.59 ± 0.03i
2.32 ± 0.04j

T2
1.75 ± 0.12gh
57.22 ± 2.56c
464.16 ± 26.33a
1.33 ± 0.08def
96.94 ± 0.08j
1.73 ± 0.09d

T3
0.66 ± 0.01bc
65.79 ± 3.95a
613.59 ± 30.68d
1.43 ± 0.03fk
95.81 ± 0.02k
0.76 ± 0.08k

7d

T1
1.15 ± 0.05ef
43.29 ± 0.87e
403.70 ± 7.55ae
2.47 ± 0.05g
94.79 ± 0.06l
2.69 ± 0.01l

T2
2.01 ± 0.16h
75.65 ± 3.02b
613.59 ± 49.08d
1.63 ± 0.05l
96.17 ± 0.02g
2.19 ± 0.02m

T3
1.75 ± 0.13gh
65.79 ± 5.52a
464.16 ± 9.28a
1.52 ± 0.08k
96.53 ± 0.05m
2.00 ± 0.06n

8d

T2
1.52 ± 0.14dg
65.79 ± 1.97a
464.16 ± 3.26a
1.92 ± 0.04h
96.04 ± 0.06n
2.05 ± 0.05n

T3
0.66 ± 0.07bc
57.22 ± 0.36c
403.07 ± 18.97ae
1.08 ± 0.03bc
91.27 ± 0.09e
1.64 ± 0.05de

Means in the same column with different letters are significantly different ().

3.6. FAA Analysis

FAAs are responsible for the formation of flavor and can be the precursor of aromatic compounds. The increase of FAA content is due to protein and peptide decomposition induced by proteolytic enzymes, while its decrease is due to the reaction of these amino acids with other compounds [40]. The major FAAs in deshelled crayfish were Arg, Thr, Ala, and Gly, which accounted for 76.08–87.92% of total FAAs (Table 2). As a flavor-stale amino acid, His of CK increased from the initial value of 23.43 mg/100 g to 30.02 mg/100 g at day 4, while the content of T0, T1, T2, and T3 were 42.70, 33.25, 36.10, and 31.78 mg/100 g at day 8, respectively. His was basically caused by the oxidation process from trimethylamine oxide based on the growth of the spoilage organism and was consistent with results of the TVB-N value. Arg, Thr, Met, Ile, and Lys showed upwards trends at the early storage and afterwards gradually decreased; however, Asp, Glu, Tyr, and His showed upwards. Ala and Gly progressively decreased during storage, which was owing to the positive enhancing effects of desired tastes and characterized by sweetness [41, 42]. The decrease of special flavor-enhancing amino acids and accumulation of flavor-detracting amino acids could lead to the flavor deterioration, and the coating with RPPE could effectively slow down the process and maintain the quality of deshelled crayfish.

Table 2: FAA contents of crayfish sample during storage at 4°C.

FAA (mg/100 g)
0d
4d
8d

0d
CK
T0
T1
T2
T3
T0
T1
T2
T3

Asp
0.23
0.74
1.12
1.35
0.59
1.10
2.13
1.28
1.97
1.55

Thr
148.62
83.68
104.36
74.56
59.79
83.13
103.88
79.88
101.68
123.19

Ser
50.23
—
—
—
7.87
4.35
10.26
—
—
15.24

Glu
9.66
17.02
15.07
18.58
8.98
12.50
23.12
79.40
21.25
17.61

Gly
54.98
34.37
58.25
24.50
19.62
54.15
31.49
54.80
27.62
38.87

Ala
127.00
74.76
118.67
79.78
72.55
87.03
96.12
125.67
93.26
86.41

Val
18.70
17.27
18.21
16.06
10.02
16.01
24.53
14.50
21.72
20.60

Met
16.54
12.15
11.58
12.38
7.29
7.83
14.12
15.06
11.73
11.52

Ile
9.80
6.18
6.97
6.48
5.36
7.41
10.65
6.22
9.76
10.39

Leu
17.80
12.22
13.12
11.56
9.27
12.97
18.82
11.31
18.45
18.95

Tyr
4.97
5.90
5.58
4.89
4.46
4.34
7.75
7.34
6.75
5.65

Phe
5.53
6.21
5.70
6.66
4.44
4.54
11.18
6.28
9.85
6.46

Lys
29.95
7.95
20.17
10.97
19.33
14.04
17.54
32.11
16.27
39.64

His
23.43
35.05
30.02
33.49
20.99
25.98
42.70
33.25
36.10
31.78

Arg
616.35
449.14
497.42
501.77
449.01
440.67
530.66
429.67
472.56
584.79

Total
1133.78
762.64
906.24
803.03
699.56
776.05
944.98
896.77
848.97
1012.65

—, not detected.

3.7. Microstructure of Crayfish Muscle

Representative SEM microstructures of crayfish muscle subjected to the RPPE treatments were compared with fresh crayfish muscle in Figure 3. We observed significant differences between the fresh crayfish muscle and those treated with RPPE both in fibers, bundles, and intramuscular connective tissues. At day 0, fresh crayfish had a complete and smooth muscle structure and a compact muscle fiber arrangement (Figure 3). Some small spaces appeared between the muscle bundles in the fresh sample, all of which indicated a well-organized structure. With the prolongation of storage time, the muscle fiber tissues in the treated groups had different degrees of deterioration. At day 8, the muscle structure of the CK and T0 samples were most degraded and the surface texture was loose and fuzzy. Although degradation was also observed in the T1 and T2 samples, the fibers, bundles, and structures were still regular in appearance. The muscle fiber of T3 was more regular, and the muscle fiber was not significantly broken. The connective tissues also adhered to each other tightly, which were very similar to those of the fresh sample. Therefore, RPPE delayed the degradation of crayfish muscle.

Figure 3: SEM images of crayfish under different treatments during storage. (a) At the beginning. (b) CK at 8th day. (c) T0 at 8th day. (d) T1 at 8th day. (e) T2 at 8th day. (f) T3 at 8th day.

4. Conclusion

RPPE exhibited a high amount of total phenolic and demonstrated effective antioxidant properties. Gelatin coating with RPPE and ε-PL delayed deshelled crayfish deterioration in quality parameters, such as TVB-N, K value, FAAs, and water migration and could extend deshelled crayfish shelf life by 2 days. Combined with the effect of the color of the preservation solution on the samples, the coating combined with 2.0% RPPE was preferred.

Data Availability

The data used to support the findings of this study are available from the corresponding author upon request.

Conflicts of Interest

The authors declare no conflicts of interest.

Acknowledgments

The authors would like to express their profound gratitude to Weiqiang Qiu from the Instrumental Analysis Center of Shanghai Ocean University for his technical assistance. This research was funded by the NSFC (31571914 and 31601414), China Agriculture Research System (CARS-47), National Key Research and Development Program (2016YFD0400106), Doctoral Start-Up Fund from SHOU, and Construction Project of Public Service Platform for Shanghai Municipal Science and Technology Commission (17DZ2293400).

References

M. Z. Elsabee, E. S. Abdou, K. S. A. Nagy, and M. Eweis, “Surface modification of polypropylene films by chitosan and chitosan/pectin multilayer,” Carbohydrate Polymers, vol. 71, no. 2, pp. 187–195, 2008.

Y. Shao, G. Xiong, J. Ling et al., “Effect of ultra-high pressure treatment on shucking and meat properties of red swamp crayfish (Procambarus clarkia),” LWT, vol. 87, pp. 234–240, 2018.

G. Chen and Y. L. Xiong, “Shelf-stability enhancement of precooked red claw crayfish (Cherax quadricarinatus) tails by modified CO₂/O₂/N₂ gas packaging,” LWT—Food Science and Technology, vol. 41, no. 8, pp. 1431–1436, 2008.

O. Cremades, C. Álvarez-ossorio, J. F. Gutierrez-Gil, J. Parrado, and J. Bautista, “Quality changes of cooked crayfish (Procambarus clarkii) tails without additives during storage under protective atmospheres,” Journal of Food Processing and Preservation, vol. 35, no. 6, pp. 898–906, 2011.

C. G. Hernández-Valencia, A. Román-Guerrero, Á. Aguilar-Santamaría, L. Cira, and K. Shirai, “Cross-linking chitosan into hydroxypropylmethylcellulose for the preparation of neem oil coating for postharvest storage of pitaya (Stenocereus pruinosus),” Molecules, vol. 24, no. 2, p. 219, 2019.

P. Fan, D. J. Huber, Z. Su et al., “Effect of postharvest spray of apple polyphenols on the quality of fresh-cut red pitaya fruit during shelf life,” Food Chemistry, vol. 243, pp. 19–25, 2018.

M. Amid, Y. Manap, and N. Zohdi, “A novel aqueous two phase system composed of a thermo-separating polymer and an organic solvent for purification of thermo-acidic amylase enzyme from red pitaya (Hylocereus polyrhizus) peel,” Molecules, vol. 19, no. 5, pp. 6635–6650, 2014.

H. Kim, H.-K. Choi, J. Y. Moon, Y. S. Kim, A. Mosaddik, and S. K. Cho, “Comparative antioxidant and antiproliferative activities of red and white pitayas and their correlation with flavonoid and polyphenol content,” Journal of Food Science, vol. 76, no. 1, pp. C38–C45, 2011.

B. Jamilah, C. E. Shu, M. Kharidah, M. A. Dzulkifly, and A. Noranizan, “Physico-chemical characteristics of red pitaya (Hylocereus polyrhizus) peel,” International Food Research Journal, vol. 18, no. 1, pp. 279–286, 2011.

F. Ferreres, C. Grosso, A. Gil-Izquierdo, P. Valentão, A. T. Mota, and P. B. Andrade, “Optimization of the recovery of high-value compounds from pitaya fruit by-products using microwave-assisted extraction,” Food Chemistry, vol. 230, pp. 463–474, 2017.

Q. He and K. Xiao, “The effects of tangerine peel (Citri reticulatae pericarpium) essential oils as glazing layer on freshness preservation of bream (Megalobrama amblycephala) during superchilling storage,” Food Control, vol. 69, pp. 339–345, 2016.

A. N. Adilah, B. Jamilah, M. A. Noranizan, and Z. A. N. Hanani, “Utilization of mango peel extracts on the biodegradable films for active packaging,” Food Packaging and Shelf Life, vol. 16, pp. 1–7, 2018.

Z. Shad, H. Mirhosseini, A. S. M. Hussin, B. Forghani, M. Motshakeri, and M. Y. A. Manap, “Aqueous two-phase purification of α-amylase from white pitaya (Hylocereus undatus) peel in polyethylene glycol/citrate system: optimization by response surface methodology,” Biocatalysis and Agricultural Biotechnology, vol. 14, pp. 305–313, 2018.

X. Carrión-Granda, I. Fernández-Pan, J. Rovira, and J. I. Maté, “Effect of antimicrobial edible coatings and modified atmosphere packaging on the microbiological quality of cold stored hake (Merluccius merluccius) fillets,” Journal of Food Quality, vol. 2018, Article ID 6194906, 12 pages, 2018.

E. Choulitoudi, S. Ganiari, T. Tsironi et al., “Edible coating enriched with rosemary extracts to enhance oxidative and microbial stability of smoked eel fillets,” Food Packaging and Shelf Life, vol. 12, pp. 107–113, 2017.

M. S. Alsagga, S. H. Moussa, and A. A. Tayel, “Application of fungal chitosan incorporated with pomegranate peel extract as edible coating for microbiological, chemical and sensorial quality enhancement of Nile tilapia fillets,” International Journal of Biological Macromolecules, vol. 99, pp. 499–505, 2017.

G. Lisa, T. Catrin, and M. Alessandra, “Effect of processing on antioxidant activity, total phenols, and total flavonoids of pigmented heirloom beans,” Journal of Food Quality, vol. 2018, Article ID 7836745, 6 pages, 2018.

F. R. de Mello, C. Bernardo, C. O. Dias et al., “Antioxidant properties, quantification and stability of betalains from pitaya (Hylocereus undatus) peel,” Ciência Rural, vol. 45, no. 2, pp. 323–328, 2014.

J. Tkaczewska, M. Morawska, P. Kulawik, and M. Zając, “Characterization of carp (Cyprinus carpio) skin gelatin extracted using different pretreatments method,” Food Hydrocolloids, vol. 81, pp. 169–179, 2018.

A. Mansour, R. Celano, T. Mencherini et al., “A new cineol derivative, polyphenols and norterpenoids from Saharan myrtle tea (Myrtus nivellei): isolation, structure determination, quantitative determination and antioxidant activity,” Fitoterapia, vol. 119, pp. 32–39, 2017.

S.-D. Zhou, X. Xu, Y.-F. Lin, H.-Y. Xia, L. Huang, and M.-S. Dong, “On-line screening and identification of free radical scavenging compounds in Angelica dahurica fermented with Eurotium cristatum using an HPLC-PDA-triple-TOF-MS/MS-ABTS system,” Food Chemistry, vol. 272, pp. 670–678, 2019.

J.-H. Kim, W.-S. Hong, and S.-W. Oh, “Effect of layer-by-layer antimicrobial edible coating of alginate and chitosan with grapefruit seed extract for shelf-life extension of shrimp (Litopenaeus vannamei) stored at 4°C,” International Journal of Biological Macromolecules, vol. 120, pp. 1468–1473, 2018.

Z. Fang, L. Zhou, Y. Wang, L. Sun, and R. Gooneratne, “Evaluation the effect of mycotoxins on shrimp (Litopenaeus vannamei) muscle and their limited exposure dose for preserving the shrimp quality,” Journal of Food Processing and Preservation, vol. 43, no. 4, Article ID e13902, 2019.

J. Shi, Y. Lei, H. Shen et al., “Effect of glazing and rosemary (Rosmarinus officinalis) extract on preservation of mud shrimp (Solenocera melantho) during frozen storage,” Food Chemistry, vol. 272, pp. 604–612, 2019.

D. Yu, Y. Xu, J. M. Regenstein et al., “The effects of edible chitosan-based coatings on flavor quality of raw grass carp (Ctenopharyngodon idellus) fillets during refrigerated storage,” Food Chemistry, vol. 242, pp. 412–420, 2018.

N. Li, Y. Shen, W. Liu, J. Mei, and J. Xie, “Low-field NMR and MRI to analyze the effect of edible coating incorporated with MAP on qualities of half-smooth tongue sole (Cynoglossus semilaevis günther) fillets during refrigerated storage,” Applied Sciences, vol. 8, no. 8, p. 1391, 2018.

M. Mushtaq, A. Gani, A. Gani, H. A. Punoo, and F. A. Masoodi, “Use of pomegranate peel extract incorporated zein film with improved properties for prolonged shelf life of fresh Himalayan cheese (Kalari/kradi),” Innovative Food Science & Emerging Technologies, vol. 48, pp. 25–32, 2018.

M. Jiang, S. Liu, and Y. Wang, “Effects of antimicrobial coating from catfish skin gelatin on quality and shelf life of fresh white shrimp (Penaeus vannamei),” Journal of Food Science, vol. 76, no. 3, pp. M204–M209, 2011.

D. Yu, Q. Jiang, Y. Xu, and W. Xia, “The shelf life extension of refrigerated grass carp (Ctenopharyngodon idellus) fillets by chitosan coating combined with glycerol monolaurate,” International Journal of Biological Macromolecules, vol. 101, pp. 448–454, 2017.

J. Jian, L. Liao, Y. Qiao et al., “The effects of vacuum package combined with tea polyphenols (V + TP) treatment on quality enhancement of weever (Micropterus salmoides) stored at 0°C and 4°C,” LWT-Food Science and Technology, vol. 91, pp. 484–490, 2018.

Q. Wang, J. Lei, J. Ma, G. Yuan, and H. Sun, “Effect of chitosan-carvacrol coating on the quality of pacific white shrimp during iced storage as affected by caprylic acid,” International Journal of Biological Macromolecules, vol. 106, pp. 123–129, 2018.

H. Fan, Y. Luo, X. Yin, Y. Bao, and L. Feng, “Biogenic amine and quality changes in lightly salt-and sugar-salted black carp (Mylopharyngodon piceus) fillets stored at 4°C,” Food Chemistry, vol. 159, pp. 20–28, 2014.

Z. Xu, X. Liu, H. Wang, H. Hong, and Y. Luo, “Comparison between the Arrhenius model and the radial basis function neural network (RBFNN) model for predicting quality changes of frozen shrimp (Solenocera melantho),” International Journal of Food Properties, vol. 20, no. 11, pp. 2711–2723, 2017.

S. Wu, “Effect of chitosan-based edible coating on preservation of white shrimp during partially frozen storage,” International Journal of Biological Macromolecules, vol. 65, pp. 325–328, 2014.

J. Sun, R. Zhang, Y. Zhang et al., “Classifying fish freshness according to the relationship between EIS parameters and spoilage stages,” Journal of Food Engineering, vol. 219, pp. 101–110, 2018.

M. K. Morsy, E. Mekawi, and R. Elsabagh, “Impact of pomegranate peel nanoparticles on quality attributes of meatballs during refrigerated storage,” LWT, vol. 89, pp. 489–495, 2018.

T. Saito, K.-I. Arai, and M. Matsuyoshi, “A new method for estimating the freshness of fish,” Nippon Suisan Gakkaishi, vol. 24, no. 9, pp. 749-750, 1959.

T. Li, J. Li, W. Hu, X. Zhang, X. Li, and J. Zhao, “Shelf-life extension of crucian carp (Carassius auratus) using natural preservatives during chilled storage,” Food Chemistry, vol. 135, no. 1, pp. 140–145, 2012.

T. Li, Y. Jiang, G. Jin, Q. Zhao, and J. Li, “Effects of fish-derived biological preservatives on cold storage of grass carp (Ctenopharyngodon idellus) fillets,” Journal of Food Protection, vol. 79, no. 10, pp. 1707–1716, 2016.

X. Yin, Y. Luo, H. Fan, H. Wu, and L. Feng, “Effect of previous frozen storage on quality changes of grass carp (Ctenopharyngodon idellus) fillets during short-term chilled storage,” International Journal of Food Science & Technology, vol. 49, no. 6, pp. 1449–1460, 2014.

K. Itou and Y. Akahane, “Changes in proximate composition and extractive components of rice-bran-fermented mackerel heshiko during processing,” Nippon Suisan Gakkaishi, vol. 66, no. 6, pp. 1051–1058, 2000.

M. Takahashi, N. Hirose, S. Ohno, M. Arakaki, and K. Wada, “Flavor characteristics and antioxidant capacities of hihatsumodoki (Piper retrofractum vahl) fresh fruit at three edible maturity stages,” Journal of Food Science and Technology, vol. 55, no. 4, pp. 1295–1305, 2018.